A.J.Antunes roundup ES-600 Manual del usuario - Página 10

Navegue en línea o descargue pdf Manual del usuario para Cocedor de huevos A.J.Antunes roundup ES-600. A.J.Antunes roundup ES-600 16 páginas. Egg station

Imprimir página

EGG STATION (ES-600 & ES-1200)

Checking Cycle Times (Monthly)

CAUTION: Grill surfaces will be hot. Care should

be taken when operating this piece of equipment.

NOTE: A stopwatch is required for this procedure.

1. Turn the Rocker Switch (power On/Off) to ON.

Allow the unit to preheat for 30 minutes.

2. Ensure that the #1 Time Selector Button (2'-00")

is lit. If not, press and release the #1 button. This

button should now be lit.

3. With the stopwatch in hand, press and release the

Start/Stop cycle switch and start the stopwatch.

4. Record the time when the Bacon light begins

to flash (if the Bacon Timer is enabled). Then,

record the time when the Cooking light turns off.

5. Repeat this test with the Time Selector button set

at 2'-30".

When set at 2'-00", the Bacon light should flash

at 1 minute and 30 seconds (90 seconds), and

the Cooking light should turn off at 2 minutes (120

seconds).

When set at 2'-30", the Bacon light should flash

at 2 minutes (120 seconds), and the Cooking light

should turn off at 2 minutes and 30 seconds (150

seconds).

All times are to be within +/- five (5) seconds.

6. Turn the Rocker Switch (Power On/Off) to OFF.

Figure 4. ES-600 Shown

MAINTENANCE (continued)

Checking Grill Platen Temperature

NOTE: A pyrometer is required for this procedure.

This procedure exposes you to hot surfaces. Use

extreme care when performing procedure to avoid

personal injury.

Grill

Platen

WARNING

1. Move the cover and the Egg Rack by lifting the

whole assembly until clear of the base.

2. Turn the Rocker Switch (power On/Off) to the ON

position. Allow 30 minutes for the unit tempera-

ture to stabilize.

3. Using a pyrometer, measure the temperature at

the middle of the Platen surface (Figure 4). The

temperature should be 250° F (121° C) to 300° F

(149° C)

If temperature is within range, proceed to Step 4.

If temperature is above or below the proper

calibrated range, call your Authorized Service

Agency.

4. Turn the Rocker Switch (power On/Off) to the

OFF position.

5. Reinstall cover and Egg Rack and cover.

2'-00"

2'-30"

POWER

NOTE: The following are factory pre-set cooking times.

Time 1 Button: 2 minute cooking time.

Time 2 Button: 2 minutes and 30 seconds cooking time.

Figure 3. Time Selector Switch

READY

BACON

COOKING

START/STOP

P/N 1010883 08/05 Rev. A