Kohler Courage SV735 Owner's Manual - Page 18

Browse online or download pdf Owner's Manual for Engine Kohler Courage SV735. Kohler Courage SV735 21 pages. Vertical crankshaft
Also for Kohler Courage SV735: Owner's Manual (21 pages), Owner's Manual (8 pages)

Print Page

FEDERAL AND CALIFORNIA EMISSION CONTROL SYSTEMS

The U.S. Environmental Protection Agency (EPA), the California Air Resources Board (CARB), and Kohler Co. are pleased to explain the Federal

and California Emission Control Systems Warranty on your small oﬀ-road equipment engine. In California beginning in 2006 "emissions"

means both exhaust and evaporative emissions. For California, engines produced in 2006 and later must be designed, built and equipped

to meet the state's stringent anti-smog standards. In other states, 1997 and later model year engines must be designed, built and equipped,

to meet the U.S. EPA regulations for small non-road engines. The engine must be free from defects in materials and workmanship which cause

it to fail to conform with U.S. EPA standards for the ﬁrst two years of engine use from the date of sale to the ultimate purchaser. Kohler Co. must

warrant the emission control system on the engine for the period of time listed above, provided there has been no abuse, neglect or improper

maintenance.

The emission control system may include parts such as the carburetor or fuel injection system, the ignition system, and catalytic converter.

Also included are the hoses, belts and connectors and other emission related assemblies.

Where a warrantable condition exists, Kohler Co. will repair the engine at no cost, including diagnosis (if the diagnostic work is performed at

an authorized dealer), parts and labor.

MANUFACTURER'S WARRANTY COVERAGE

Engines produced in 2006 or later are warranted for two years in California. In other states, 1997 and later model year engines are warranted

for two years. If any emission related part on the engine is defective, the part will be repaired or replaced by Kohler Co. free of charge.

OWNER'S WARRANTY RESPONSIBILITIES

(a)

The engine owner is responsible for the performance of the required maintenance listed in the owner's manual. Kohler Co. recommends that

you retain all receipts covering maintenance on the engine, but Kohler Co. cannot deny warranty solely for the lack of receipts or for

your failure to assure that all scheduled maintenance was performed.

(b)

Be aware, however, that Kohler Co. may deny warranty coverage if the engine or a part has failed due to abuse, neglect, improper

maintenance or unapproved modiﬁcations.

(c)

For warranty repairs, the engine must be presented to a Kohler Co. service center as soon as a problem exists. Call 1-800-544-2444 or

access our website at: www.kohlerengines.com, for the names of the nearest service centers. The warranty repairs should be completed

in a reasonable amount of time, not to exceed 30 days.

If you have any questions regarding warranty rights and responsibilities, you should contact Kohler Co. at 1-920-457-4441 and ask for an Engine

Service representative.

COVERAGE

Kohler Co. warrants to the ultimate purchaser and each subsequent purchaser that the engine will be designed, built and equipped, at the

time of sale, to meet all applicable regulations. Kohler Co. also warrants to the initial purchaser and each subsequent purchaser, that the

engine is free from defects in materials and workmanship which cause the engine to fail to conform with applicable regulations for a period

of two years.

Engines produced in 2006 or later are warranted for two years in California. For 1997 and later model years, EPA requires manufacturers

to warrant engines for two years in all other states. These warranty periods will begin on the date the engine is purchased by the initial

purchaser. If any emission related part on the engine is defective, the part will be replaced by Kohler Co. at no cost to the owner. Kohler Co. is

liable for damages to other engine components caused by the failure of a warranted part still under warranty.

Kohler Co. shall remedy warranty defects at any authorized Kohler Co. engine dealer or warranty station. Warranty repair work done at an

authorized dealer or warranty station shall be free of charge to the owner if such work determines that a warranted part is defective.

Listed below are the parts covered by the Federal and California Emission Control Systems Warranty. Some parts listed below may require

scheduled maintenance and are warranted up to the ﬁrst scheduled replacement point for that part. The warranted parts include the

following if they were present in the engine purchased:

•

Oxygen sensor (if equipped)

•

Intake manifold (if equipped)

•

Exhaust manifold (if equipped)

•

Catalytic muﬄer (if equipped)

•

Thermal reactor muﬄer (if equipped)

KOHLER CO.

LIMITED WARRANTY

SMALL OFF-ROAD ENGINES

•

Ignition module(s) with high tension lead

•

Gaseous fuel regulator (if equipped)

•

Electronic control unit (if equipped)

•

Carburetor or fuel injection system

•

Fuel metering valve (if equipped)

Continued on next page.