Kohler K582 Instrukcja obsługi - Strona 6

Przeglądaj online lub pobierz pdf Instrukcja obsługi dla Silnik Kohler K582. Kohler K582 17 stron. Four-cycle, twin cylinder, air-cooled engine

Drukuj stronę

Operating Instructions

Also read the operating instructions of the equipment this engine powers.

Pre-Start Checklist

Check oil level. Add oil if low. Do not overfill.

Check fuel level. Add fuel if low.

Check cooling air intake areas and external

surfaces of engine. Make sure they are clean and

unobstructed.

Check that the air cleaner components

and all

shrouds, equipment

covers, and guards are in

place and securely fastened.

Check that any clutches or transmissions

are

disengaged

or placed in neutral. This is especially

important on equipment'with

hydrostatic

drive.

The shift lever must be exactly in neutral to

prevent resistance which could keep the engine

from starting.

WARNING:

Lethal Exhaust Gases!

Engine exhaust gases contain poisonous carbon

monoxide. Carbon monoxide is odorless, colorless,

and can cause death if inhaled. Avoid inhaling exhaust

fumes, and never run the engine in a closed building

or confined area.

Cold Weather Starting Hints

1 .

4 .

Be sure to use the proper oil for the temperature

expected. See Figure 2 on page 4.

Declutch all possible external

loads.

A warm battery has much more starting capacity

that a cold battery.

Use fresh winter grade fuel. NOTE: Winter grade

gasoline has a higher volatility

to improve

starting. Do not use gasoline

left over from

summer.

Starting

1. Move the throttle control lever to IDLE (slow)

position. For engines without automatic

choke,

move choke lever into full choke position and

gradually

return to OFF position after engine

starts and warms up.

2. Start the engine as follows:

For an Electric Start Engine - Activate the

starter switch. Release the switch as soon as the

engine starts.

NOTE:

Do not crank the engine continuously

for

more than 10 seconds at a time. If the

engine does not start, allow a 60 second

cool down period between starting

attempts. Failure to follow these

guidelines

can burn out the starter motor.

NOTE:

If the engine develops sufficient

speed to

disengage the starter but does not keep

running (a false start), the engine

rotation must be allowed to come to a

complete stop before attempting

restart the engine. If the start is engaged

while the flywheel

is rotating, the starter

pinion and flywheel

ring gear may clash,

resulting in damage to the starter.

If the starter does not turn the engine over, shut

off starter immediately.

Do not make further

attempts to start the engine until the condition

corrected.

Do not jump start using another battery

(refer to "Battery" below). See your Kohler Engine

Service Dealer for trouble analysis.

Stopping

Turn ignition switch OFF.

Figure 5.

Instrument

panel is standard on basic engine. Choke,

throttle, oil pressure gauge, ammeter, start button, and

stop switch are all positioned for easy operation.

Battery

A 12 volt battery is normally used. Refer to the

operating instructions

of the equipment

this engine

powers for specific battery requirements.

If the battery charge is not sufficient to crank the

engine, recharge the battery (see page 10).