aquatherm AT550 Manual de instalação - Página 5

Procurar online ou descarregar pdf Manual de instalação para Bomba de calor aquatherm AT550. aquatherm AT550 14 páginas. Swimming pool & spa heat pumps w/titanium heat exchanger

Imprimir página
C. PLUMBING & WATER CONNECTIONS
1. BASIC PLUMBING. For a pool only
or spa only, install the plumbing piping
as shown. Connections from factory
are 2"unions. Hand tighten then 1/4 to
1/2 snug tight with pliers. Water IN on
the RIGHT, Water OUT on the LEFT.
PLUMB AFTER the FILTER & BEFORE
any CHLORINATORS or CHEMICAL
FEEDERS
2. FREEZE CONDITION PLUMBING. See WINTERIZING PROCEDURES on page 7.
3. BYPASS FOR FLOW RATES OVER 70 G.P.M. Typi-
cally the automatic internal water bypass can handle up to a
1.5 H.P. water pump or 70 G.P.M. If the water pump exceeds
1.5 H.P. then install either of the optional bypasses as shown
below. The installation of a flow meter on the WATER OUT
line is suggested. Adjust the bypass to divert a minimum of
40 to 50 G.P. M. through the heater. Flow meters should be
installed per the manufacturer's instructions.

4. MULTI UNIT WATER CONNECTIONS

Plumb multiple units as shown below. Use flow meters on each
WATER OUT line if two or more units are plumbed together.
Use ball valves to balance the water flow through each unit.
Using T's, caps and a minimum 6 inch pipe extension on the
plumbing manifold will help equalize the water flow better than
90˚'s. Flow meters should be installed per the manufacturer's
instructions.
5. POOL/SPA COMBINATIONS W/SPILL-OVER
Use this diagram for
a connected pool and
spa, where the spa has
a spill-over type wa-
terfall into the pool.
Where one pump and
one heater are used for
both the pool and spa.
If the water pump ex-
ceeds 1.5 H.P. then in-
stall a external bypass
as shown on page 5.
SEE CHLORINATOR LOOP &
CHECK VALVE REQUIREMENT
ON PAGE 5.
6" TO 8"
TO
POOL
CHLORINATOR
PUMPS OVER 70 GPM
REQUIRE BYPASS HERE
HEAT PUMP
Jandy™
3-Way Valve
POOL
SPA
TO
SPA JETS
TO SPA
SPILLOVER
CHLORINATOR
4
HEAT
PUMP
WATER
PUMP
OUT
IN
TOP VIEW
OUT
IN
FLOW
FLOW
METER
METER
FROM
TO
POOL
FILTER
TOP VIEW
OUT
IN
OUT
BALL
VALVE
FLOW
FROM
METER
FILTER
TO POOL
WATER
FILTER
PUMP
VERTICAL
CHLORINATOR
LOOP
SPA
FROM
SPA
SUCTION
TO POOL
RETURN
SKIMMER
SUCTION
FROM
POOL
OUT
IN
TO
POOL
FROM
FILTER
IN
CAP
& 6" OF PIPE
POOL
FROM
POOL
FLOOR
SUCTION
FROM
POOL