Kohler K582 Руководство пользователя - Страница 8

Просмотреть онлайн или скачать pdf Руководство пользователя для Двигатель Kohler K582. Kohler K582 17 страниц. Four-cycle, twin cylinder, air-cooled engine

Печатать страницу

Check Oil Level

The importance

of checking and maintaining

the

proper oil level in the crankcase

cannot be

overemphasized.

Check oil BEFORE EACH USE as

follows:

NOTE:

Make sure the oil level is checked BEFORE

EACH USE and is maintained

up to the "F"

mark on the dipstick. This includes engines

equipped with Oil SentryTM.

3 .

Make sure the engine is stopped, level, and is

cool so the oil has had time to drain into the

sump.

To keep dirt, grass clippings,

etc., out of the

engine, clean the area around the oil fill tube

before removing

it.

Remove the dipstick; wipe oil off. Reinsert the

dipstick and push it all the way down into the

tube.

Remove the dipstick and check the oil level.

The oil level should be up to, but not over, the "F"

mark on the dipstick. See Figure 6.

~~-

. . . . . . . . . .

0 perat i ng

. . . . . . . . .

*.'.+*.*.*.'.'.*.'

. . . . . . . . . .

:i:i::i:i:i:.:i:i:

. . . . ..a...

- . . . . . . . .

. . . . . . . . . ,

Range

:::::y:::::::::::

. . . . . . . . .

'.'.:..*.'.'.*A

. . . . . . ...*

. . . . . . . . .

'.*.-.-.*.-e*.*.-.'

. . . . . ..*.I

. . . .._ . . .

..*...*...

. . . . . . . _.

(

I:I::~

"F" Mark

Figure 6. Oil Level Dipstick.

5. If the level is low, add oil of the proper type, up to

the "F" mark on the dipstick. (Refer to "Oil Type"

on page 4.) Always check the level with the

dipstick before adding more oil.

NOTE:

To prevent extensive

engine wear or

damage, always maintain the proper oil

level in the crankcase.

Never operate

the engine with the oil level below the "L"

mark or over the "F" mark on the

dipstick.

Oil SentryTM

Some engines are equipped with an optional Oil

SentryTM oil pressure switch. If the oil pressure

decreases

below an acceptable

level, the Oil SentryTM

will either shut off the engine or activate a warning

signal, depending

on the application.

Change Oil and Oil Filter

Change Oil

For a new engine, change oil after the first 5 hours

of operation. Thereafter,

change oil after every 50

hours of operation.

Change the oil while the engine is still warm. The oil

will flow freely and carry away more impurities.

Make

sure the engine is level when filling, checking,

changing the oil.

Chanae the oil as follows:

3 . Fill with new oil of the proper type to the 'IF" mark

on the dipstick. Always check the level on the

dipstick before adding more oil.

NOTE:

To prevent extensive

engine wear or

damage, always maintain the proper oil

level in the crankcase.

Never operate

the engine with the oil level below the "L"

mark or over the "F" mark on the

dipstick.

Change Oil

Replace the

Remove the oil drain plug. Tilt the engine slightly

towards the oil drain to obtain better drainage.

Reinstall the drain plug. Make sure it is tightened

securely.

Filter

oil filter every 100 hours of operation.

Always use a genuine Kohler oil filter, Part No.

277233.

Replace the oil filter as follows:

Drain the crankcase

oil first, then remove the old

oil filter. Use a 1" hex. wrench and turn the filter

counterclockwise

to remove.

Place a new replacement

filter in a shallow pan

with the open end up. Pour new oil of the proper

type, in through the threaded center hole. Stop

pouring when the oil reaches the bottom of the

threads.

Put a drop of oil on your fingertip and wipe it on

the rubber gasket. Allow a minute or two for the

oil to be absorbed by the filter material then

install it on the engine.