Alemite 7341 Servis Kılavuzu - Sayfa 10
Araçlar Alemite 7341 için çevrimiçi göz atın veya pdf Servis Kılavuzu indirin. Alemite 7341 16 sayfaları. High-capacity
Ayrıca Alemite 7341 için: Servis Kılavuzu (12 sayfalar)
Sayfayı Yazdır
Clamp attached to sheave assembly
Adjusting spring tension
CAUTION
Do not overwind the power spring.
Too much tension reduces the life of the
spring.
When the hose is fully extended from
the reel, the power spring should be a
minimum of
/
turn from a fully wound
1
2
condition.
18 Release all pressure within the system.
WARNING
Disconnect the air supply line to the
pump's motor.
Into an appropriate container, operate
the control valve to discharge remaining
pressure within the system.
19 Remove the control valve and the hose
stop from the delivery hose.
20 Pull the free end of the delivery hose
through the guide.
21 Rotate the Sheave Assembly in the
required direction.
22 Install the control valve and the hose
stop.
23 Pressurize the system.
24 Check to ensure the tension on the
power spring is sufficient to properly
hold the hose stop against the hose
guide.
25 Repeat steps 18 - 24 until the proper
tension is achieved.
10
Reel operation
Fig. 4
WARNING
Do not exceed lowest pressure
rating of any component in system.
Never point a control valve at any
portion of body or another person.
Lubricant discharged at high velocity
can penetrate skin and cause severe
injury. Should any fluid appear to
puncture skin, get medical care
immediately.
Ensure all components are in
operable condition. Replace any suspect
parts prior to operation. Personal injury
can occur.
Hold delivery hose securely until reel
is securely latched or fully retracted.
Uncontrolled retraction can result in
personal injury.
Latch lockout
Over-rotation of the reel
NOTE
Do not extend the hose from the reel too
rapidly. Too much velocity (when the
hose is fully extended) can cause the
reel to over-rotate and latch.
Should latch lockout occur, pulling on the
hose will not release the latch mechanism.
With the reel latch in this condition it will
be necessary to have an assistant maintain
tension on the hose while the latching
mechanism is manually released.
WARNING
The reel is under maximum spring
tension. Personal injury can occur.