Atlantic Ultraviolet SANITAIRE RSM2680 Експлуатація та технічне обслуговування установки - Сторінка 12

Переглянути онлайн або завантажити pdf Експлуатація та технічне обслуговування установки для Аксесуари Atlantic Ultraviolet SANITAIRE RSM2680. Atlantic Ultraviolet SANITAIRE RSM2680 16 сторінок. Germicidal ultraviolet room air sanitizers

Друкувати сторінку

MAINTENANCE

Always disconnect power to the fixture before performing any service or maintenance.

The SANITAIRE

•

A regular cleaning cycle of the STER-L-RAY

and carefully maintained, based on inspection and experience. The frequency of cleaning will vary with the conditions

surrounding each use. It is recommended that the ultraviolet lamps be cleaned at least once every three (3) months.

•

The STER-L-RAY

life of 10,000 hours. Lamps may operate longer than their rated effective life, but the reduction in ultraviolet output will make

it impractical to use past the manufacturer's rated life. For maximum efficiency lamp replacement is recommended every

10,000 hours of operation or about one (1) year of continuous use.

•

Unless lamp replacement is due to failure or breakage, it is recommended that all lamps be replaced at the same time.

overridden and the Access Door open will expose personnel to direct or strongly reflected germicidal ultraviolet rays.

Germicidal ultraviolet rays are harmful to the eyes and skin.

equired

uPPlies

•

Vacuum cleaner

•

Soft, clean, lint-free cloth

•

Denatured alcohol

amP

nstallation

IN ORDER TO PERFORM THIS TASK, BE SURE TO WEAR THE FOLLOWING SAFETY

EQUIPMENT: SAFETY GLASSES OR A FACE SHIELD, AS WELL AS GLOVES.

Always disconnect power to the fixture before performing any service or maintenance.

Ultraviolet lamp(s) are easily damaged and may cause injury if broken. Exercise care when handling.

Lamps require regular replacement and should be replaced when the Lamp Replacement Indicators, located on the front

monitor display changes from glowing GREEN to YELLOW or RED (Flashing).

Disconnect power to the fixture and unplug from the electrical outlet.

Unlock and open the front and rear doors of the SANITAIRE

Remove each STER-L-RAY

out of the upper lamp clip. Once lamp base is free from upper lamp clip, pull pin end out of lampholder and remove it from

the unit. Repeat until all lamps have been removed from the unit. (Follow "Lamp Installation" Pages 8–9 in reverse order.)

Moisten a clean, lint-free cloth with denatured alcohol and clean all STER-L-RAY

When STER-L-RAY

of the unit with a soft dry cloth, or vacuum.

6. To remove any dust, dirt, fingerprints, smears, etc, from the outer surfaces of the SANITAIRE

Air Sanitizer, moisten a clean, lint-free cloth with denatured alcohol and wipe down the unit. Buff out any streaks, left from

the cleaning, using a soft dry cloth.

When installing the new or cleaned lamps, carefully examine the pin configuration on the lamps base to ensure that the lamp

is installed correctly into the lamp socket. (See "Lamp Installation" on Pages 8–9)

8. Begin installing the STER-L-RAY

supporting the top base of the lamp. When bottom of lamp is inserted into lampholder, snap top base into the upper lamp clip.

(See "Lamp Installation" on Pages 8–9)

9. Verify that STER-L-RAY

10. Repeat until all STER-L-RAY

11. Restore power to the fixture.

Germicidal ultraviolet rays are harmful to the eyes and skin.

Verify lamp operation by viewing the Front Monitor Display located on the front door of the unit (See Figure 3 on Page 7). If the

lamps do not appear as if they are operating properly, go to "Troubleshooting" section of this manual on Page 14.

is designed to operate with a minimal amount of maintenance.

Germicidal Ultraviolet Lamps used in the SANITAIRE

Do not override the safety interlock switch. Operation of the fixture with the interlock switch

, r

ePlaCement or

lamp starting with the closest by holding the lamp by the base and carefully pulling the lamp

lamps have been removed, cleaned, and safely set aside, remove any loose dust or dirt from the interior

lamps in the center row, inserting the 4-pin end of the lamp into the lampholder while

lamps are properly seated.

lamps have been properly reinstalled.

Avoid exposure to direct or reflected germicidal ultraviolet rays.

Germicidal Lamps, interior, and intake filter(s) MUST be established,

leaning

to gain access to the interior of the unit.

have a manufacturer's rated average effective

lamps.

Germicidal Ultraviolet Room