Coldelite KW-77 Betriebshandbuch - Seite 13

Blättern Sie online oder laden Sie pdf Betriebshandbuch für Getränkedispenser Coldelite KW-77 herunter. Coldelite KW-77 15 Seiten. Counter model whipped topping dispenser

Seite drucken

Part VIII – Periodic Cleaning

Procedures

Cleaning and sanitizing schedules for your

dispenser are determined by your local Health

Department and / or Department of Agriculture

and must be followed accordingly. Check with

your local organization prior to determining your

cleaning schedule.

After determining your schedule, proceed as

follows:

Press the "OFF button"

On the front touch pad.

To drain the remaining liquid mix from the

dispenser, place a pail under the front drain plug

next to the front panel. Remove the front drain

plug, then slowly remove the hook drain plug

from inside the mix tank. The liquid mix will

now drain from the dispenser. Using the spatula

provided in the spare parts kit, direct the

remaining liquid mix to the drain hole in the mix

tank. Replace the hook drain plug into the mix

tank drain hole.

Fill the mix tank with 6 quarts of luke warm (80-

90F) water and a non-foaming dish washing

detergent solution. Press the "Power ON" button

on the front touch pad. Press the "Dispense"

button on the front touch pad, and dispense

approximately 12 ounces liquid.

Press the "Power OFF'

button on the front

touch pad.

To drain the remaining soap solution from the

dispenser, place a pail under the front drain tube

next to the front panel. Slowly remove the hook

drain plug from inside the mix tank. The soap

solution will now drain from the dispenser. Using

the spatula, direct the remaining soap solution to

the drain hole in the mix tank.

With the machine completely drained, you must

now disassemble, clean, sanitize and reassemble

your dispenser. Proceed and follow the

instructions as described in Part III of this

manual, Initial Cleaning Procedure.

IX – Technical Information

Model KW-77 – 120Vac/60Hz/Air

A) Refrigeration

Compressor MFG. – Danfoss

Horsepower – 0.17

FLA. – 1.1 amps

Locked Rotor Amps – 11.4 amps

Low Side Pressure – 14 psig

High Side Pressure – 140 psig

Condenser Cooling – Air

Refrigerant Type – R134a

OFF

Refrigerant Amount – 3.5 ounces

Metering type – Capillary tube

Condenser Fan Motor

Horsepower – 0.01

Full Load Amps – 0.88

RPM – 3000

B) Pump Drive Motor

Motor MFG. – General Electric

Motor Type – CSIR / ODP

Horsepower – 0.5

Full Load Amps – 8.8

Overload Type – Manual / Internal

Reset Location – Rear of motor casing

OFF