GAC EEG6550 Series Handbuch - Seite 3

Blättern Sie online oder laden Sie pdf Handbuch für Schalter GAC EEG6550 Series herunter. GAC EEG6550 Series 13 Seiten. Enhanced electronic governor

Seite drucken
GAC EEG6550 Series Handbuch
4
WIRING
A
B
Ground to Case
Actuator
0-2.5 v or 4-20 ma* varIaBle SPeeD InPUT
*
4-20mA input requires an external 200 Ω resistor across Terminals H & J
If EEG detects no input from the magnetic pickup, the EEG will set the actuator to 0V and set the speed to 0 RPM. The display
will flash the RPM along with the Warning Indicator. Parameters will be unchangeable.
When installing controller be sure there's a good connection between the case of the EEG6500 and the chassis
ImPorTanT
/ battery ground.
TermInal
DefInITIon
A
Actuator (+)
B
Actuator (-)
C
Magnetic Pickup (+)
D
Magnetic Pickup (-)
E
Battery (-)
F
Battery (+)
G
Speed Switch (SSW
H
Ground Signal
J
Variable Speed Input
K
Droop Select
L
Idle Select
M
Aux Input
N
CAN L
P
CAN H
1. Shielded cable should be used for all external connections to the EEG control. One end of each shield, including the speed sensor shield, should be
grounded to a single point on the EEG case.
2. Case should be grounded
C
D
E F
Magnetic
Speed
Pickup
-
+
Battery
(12V or 24V)
GaUGe / mm
2
16 / 1.31
16 / 1.31
20 / 0.52
* Twisted wires 14 turns per foot. 0.02in (.51mm) gap between sensor and gear teeth.
20 / 0.52
16 / 1.31
A 15 amp fuse must be installed in the positive battery lead to protect against any over-
16 / 1.31
load or short circuit
Speed switch relay; normally open (nO) or normally closed (nC)
)
16 / 1.31
Reference for variable speed/trim input & switches
5K Ω Resistive, 0-2.5 V DC or 4-20 mA. Increasing voltage or resistance of current
20 / 0.52
increases speed.
16 / 1.31
Active when connected to Terminal H
16 / 1.31
Active when connected to Terminal H
20 / 0.52
Load sharing / synchronizing, 5V nominal (0-10 V), configurable polarity
20 / 0.52
Twist wires 14 turns per foot.
20 / 0.52
recommenDaTIonS
N P
5K Ω reSISTIve SPeeD TrIm PoT
A
B
C
D
A
E
B
EEG6550 Enhanced Electronic Governor 5-2020-A1
3
Governors America Corp. © 2020 Copyright All Rights Reserved
5K
Variable Speed / Trim
Potentiometer
F
C
G
D
H
E
J
F
K
G
L
H
VSPD
Droop
COM
Idle
noTeS
120 Ohms
( End of CAN bus)
M
J
N
K
P
L
M
N
Ground to
Case
CAN J1939
( Optional )
Accessory
Input
Ground to
Case
PIB1118