3M Versaflo TR-300+ Technisches Bulletin - Seite 6
Blättern Sie online oder laden Sie pdf Technisches Bulletin für Produkt für die Atemwege 3M Versaflo TR-300+ herunter. 3M Versaflo TR-300+ 8 Seiten. Powered air purifying respirator (papr)
Auch für 3M Versaflo TR-300+: Technisches Bulletin (3 seiten), Technisches Bulletin (3 seiten), Schnellstart-Handbuch (2 seiten)
Seite drucken
3M Personal Safety Division
When going through a decontamination shower, the TR-300, TR-300+, and TR-600 PAPR should be in the vertical (upright)
position as worn around the waist. 3M does not recommend a TR-600 PAPR mounted on t he BPK-01 backpack be
worn through a decontamination shower. It is preferred the unit remain running during the decontamination shower,
however, it can be turned off if required. The motor/blower unit without a breathing tube attached cannot be taken through
a decontamination shower as water may enter the motor/blower unit through the air outlet. If the user removes their
headgear, ensure the breathing tube remains attached and allowed to dangle towards the floor to ensure water does not
enter the breathing tube or the motor/blower unit. After going through the shower ensure all outer surfaces are wiped off
before disassembling the system. All system components should be thoroughly dry before storage or next use.
Storage
Motor/Blower
Store in a clean, contaminant free environment, protected from prolonged exposure to heat, sunlight, radiation and chemicals.
For prolonged storage, the motor/blower should be run at least once per year for 5 minutes to ensure continued proper
lubrication of the motor.
: Respirators used for emergency purposes must be inspected monthly per OSHA 29CFR1910.134. This should include
NOTE
running the motor/blower.
Filters and Filter Accessories
HE filter, prefilter, and spark arrestor/prefilter should be stored at temperatures and conditions similar to the motor/blower.
Store the filter and spark arrestors in the original 3M packaging until ready for installation in the motor/blower. HE filters should
not be stored long-term on the motor/blower as this may damage the filter gasket. HE filters have a shelf life of 5 years when
stored in their original packaging.
Battery Pack
Refer to the appropriate Chargers and Battery Packs User Instructions and
for 3M™ Versaflo™ Respirators
Battery packs should be charged immediately and fully upon receipt. The battery should be fully recharged after each use and
at least every 9-12 months depending on the battery.
Recommended storage conditions: -22º F (-30º C) to 122º F (50º C); Optimal: 59º F (15º C). Dry conditions, relative humidity
< 85%.
The battery pack may be stored indefinitely on the charger. The battery pack should be disconnected from the motor/blower
during storage.
Table A . Acceptable Cleaners for Wiping Down TR-300, TR-300+ and TR-600 Components
Mild dish detergent and water (Dawn, etc.)
70% Isopropyl Alcohol (IPA)
1:10 ratio of bleach to water (0.5% sodium hypochlorite)
3M™ 504 Respirator Cleaning Wipes
6
for additional information.
Technical Data Bulletin 223 Battery Maintenance