Kohler 1.4BEOR-12V Operación - Página 21
Navegue en línea o descargue pdf Operación para Generador portátil Kohler 1.4BEOR-12V. Kohler 1.4BEOR-12V 44 páginas. Heavy duty truck mobile generator sets
Imprimir página4.1 Problems, Causes and
Solutions
This section contains generator set troubleshooting,
diagnostic, and repair information.
Use the following table as a quick troubleshooting
reference. The table groups generator set faults and
suggests likely causes and remedies. The table also
refers you to more detailed information including
sections of this manual, the generator set service
manual, the generator set installation manual, and the
engine service manual to correct the indicated problem.
Corrective action and testing often require knowledge of
electrical and electronic circuits. To avoid additional
problems caused by incorrect repairs, have an
authorized Kohler distributor/dealer perform service.
Problem
Engine does not start
Starts and stops
TP-6687
9/10
Possible Cause
Incorrect injection timing.
Rings worn or sticking.
Valves sticking.
Loose cylinder locknuts.
Obstructed fuel line.
Air leaks in fuel system.
Clogged tank vent hole.
Injector sticking.
Injection pump valve sticking.
Faulty fuel feeding pump.
Fuel filter clogged.
Discharged battery.
Cable connections uncertain or incorrect.
Faulty starting switch.
Faulty starting engine.
Controller options GM75866-KP1 and
GM75866-KP2: Reached maximum of
5 automatic restarts.
Clogged air filter.
Governor linkage wrongly set.
Low idle speed.
Fuel filter clogged.
Air leaks in fuel system.
Clogged tank vent hole.
Faulty fuel feeding pump.
Section 4 Troubleshooting
Maintain a record of repairs and adjustments performed
on the equipment. If the procedures in this manual do
not explain how to correct the problem, contact an
authorized Kohler distributor/dealer. Use the record to
help describe the problem and repairs or adjustments
made to the equipment. See Appendix B, Operating
Hour Service Log.
4.2 Mechanical Components
The table below lists mechanical components of the
system and describes the problems that may occur
while the 1.4BEOR is running. Use this troubleshooting
chart to identify possible causes and relevant solutions.
Use authorized technicians when specified.
Solution
See your authorized Kohler distributor/dealer.
Replace the fuel filter.
Charge battery; see equipment manufacturer's
instructions.
See your authorized Kohler distributor/dealer.
Reset by turning the Machine Status Switch to
position 0 and back to the automatic mode.
Clean or replace air filter. See Section 5.4, Air
Filter.
See your authorized Kohler distributor/dealer.
Replace the fuel filter.
Bleed air lines. See TP-6689 or your authorized
Kohler distributor/dealer.
See your authorized Kohler distributor/dealer.
Section 4 Troubleshooting
21