ADVANCED EV EV1 Manuel - Page 16
Parcourez en ligne ou téléchargez le pdf Manuel pour {nom_de_la_catégorie} ADVANCED EV EV1. ADVANCED EV EV1 18 pages.
Imprimer la page
Maintenance
C=Check CA=Check Adjust R=Replace S=Service CL=Clean and Lubricate L=Lubricate
20 rounds
125
20 hours
rounds
20 hours
125 hours
Pre-
Remarks
160kms(
600 miles
Operation
Every
1000kms (
)
Month
Every 6
Charge
Clean Battery tops,for
tightness of hold-down screws
and terminals
Check brake pedal freeplay and
adjust if necessary
Check steering operation
Check tire pressure tread
depth tire surface for damage
Check bode and chassis,for damage
Check tightness of all bolts,nuts and
screw
Check reverse buzzer
Check electrolyte level
C h e c k f o r l o o s e o r b r o k e n
connectionsw
C l e a n L u b e P e d a l
control area
Check all wire insulation for crack
and/or worn spots
Check shock absorbers for oil
leaks and damaged springs
Perform a discharge test
protectant
Check shoe lining thickness
and rear axle beating play
C h e c k s t e e r i n g k n u c k l e
bushing freeplay/Adjust wheel
alighment
Check wheel not tightness
front wheel bearing play
Check gear box oil level and
leakage
Check operation and adjust pedal
stop if necessary
Replace gear box oil
C h e c k
f o r
g r e a s e
leakage;adjust gear box if
Items without a page number referene should be serviced by approved
agent or qualified technician.
This manual doesn't contain these procedures.They are containerd in the
Service Manual
26
500 rounds
250 rounds
1000
250 hours
500 hours
rounds
2500 miles
1000 hours
1200 miles
4000kms(
1000kms(
5000 miles
Page
Every 2
Every
8000kms
Years)
Years)
(Every 4
Storage
Perform the following preparations when
leaving your golf car unused for a long
time:
NOTE:
Turn the main switch key to the "OFF"
position, remove the key, and put it in a
safe place.
CHASSIS PREPARATION
1. Verify the air pressure of the tire is
25psi (4kgf/cm3);
2. Clean the outside of the car with
anti-rust oil;
3. Cover the car and store it in a dry and
well-ventilated place.
BATTERY PREPARATION
1. Recharge the batteries and check the
fluid levels at least once a month.
2. Disconnecting cables in case of long
storage.
CAUTION
Cleaning products are forbidden to
put into battery cells
3. Clean the top of the batteries with
baking soda and water so as to avoid
erosion.
27