Follett VU155B Panduan Pemasangan, Pengoperasian, dan Servis - Halaman 8
Jelajahi secara online atau unduh pdf Panduan Pemasangan, Pengoperasian, dan Servis untuk Dispenser Minuman Follett VU155B. Follett VU155B 20 halaman. Ice and beverage dispensers
Halaman Cetak
Connecting beverage lines
1. Connect syrup and water lines. Non-carbonated water line will be labeled "water" . Syrup lines are numbered
and correspond to the valves as shown in drawing(s) below. Valve one is always next to ice tower.
2. The center 4 valves are pre-plumbed to both carbonated and non-carbonated water lines with the
QuickCARB
beverage manifold. Valves can be individually changed from a carbonated to a non-carbonated
™
flavor with the flip of a lever (see below).
3. Clean and sanitize beverage lines according to cleaning instructions.
Valve position #1 is always next to ice
tower. Right-hand unit shown.
10
9
8
7
6
5
Operation
How the dispenser works
Follett's dispensers are available in automatic load
configurations, fed from one or two Follett RIDE
model ice machines or manual load configurations
(using ice from another source).
In all models, ice is stored below the counter in the
dispenser storage area. When the dispense lever
or button is pushed, the dispense motors are
activated. This causes the wheel assembly in the
storage area to turn, moving ice to the vertical
auger assembly, which carries ice up to the
dispense chute where it drops by gravity into the
container.
In automatic load units, ice is manufactured in
either one or two Follett RIDE model ice machines.
These ice machines may be located up to 20 ft (6
m) away from the dispenser. Extruded ice is
transported through a tube and pushed to the
storage compartment of the dispenser. When the
bin is filled, a bin thermostat shuts the ice machine
off to avoid overfilling of the bin. The ice machine
will restart after 20 minutes if the bin is calling for
ice.
Units with integral ice water bath beverage cooling
are equipped with a water bath timer circuit that
activates the water bath pump for 35 minutes when
ice lever or button is activated, or when the ice
water bath warms up and calls for more ice.
2
1
4
3
VU155B QuickCARB manifold
(see dispenser for model specific
QuickCARB configuration)
Rear View
non-carbonated
Ice movement
8
carbonated