aion ASTRA SILICON FUZZ Manual - Halaman 5

Jelajahi secara online atau unduh pdf Manual untuk Pedal Musik aion ASTRA SILICON FUZZ. aion ASTRA SILICON FUZZ 10 halaman.

BUILD NOTES

Transistor selection

The original Astrotone used 2N3565 transistors, which varied widely in gain. Some batches were in the

180-220 range. similar to the 2N3904, and others were more like 400-500, similar to the 2N5088. The

lower-gain ones were more prevalent.

The exact gain characteristics of the 2N3565 transistors used in the original Astrotone are not known,

but it doesn't matter too much. The important thing to know is that there is nothing special about the

original vintage transistors. The 2N3904 will sound exactly the same.

Diode selection

Photos of original Astrotone units show that it used DO-7 glass case diodes, which are usually

associated with germanium. However, the

original manual for the Astrotone

claims it uses all silicon

semiconductors (which includes diodes)—and in the 1960's when small-signal silicon diodes were first

coming on the market, there were a lot of them in the DO-7 case, since that was the format used by most

diodes. Therefore, while DO-7 silicon diodes are rare today, this would not be uncommon to see in 1966.

The other evidence in favor of them being silicon is more practical: since they're hard clippers with no

gain recovery afterward, they would directly impact the max volume level. At ~0.3V forward voltage

(typical for germanium), it would clamp the maximum volume at unity or lower, and the original units

would have a hard time achieving unity gain if they were in fact germanium diodes.

So, on balance, we'd conclude that despite looking like germanium didoes, the Astrotone was an early

adopter of silicon diodes. And allowing that they are in fact silicon, the standard 1N914 would be an

exact replacement.

Analogman mods

The Analogman version of the Astrotone uses 1M2 for R1 and R4, 470R for R6, and 470n for C1 and C4.

The vintage version is very thin-sounding, lacking in bass, and these modifications help to round it out.

Even if you stick with the original vintage circuit, you may find it worthwhile to use Analogman's tone

control modification, which reduces R6 to 470R. All the tones of the original unit are still present except

at the very extreme end of the range.

ASTRA SILICON FUZZ