Astra G-100 MES Manuale di installazione e sfruttamento - Pagina 8

Sfoglia online o scarica il pdf Manuale di installazione e sfruttamento per Caldaia Astra G-100 MES. Astra G-100 MES 19.

Stampa la pagina

Clean boiler chambers from smoke-black and pitch scurf once or twice a month. Clean the

boiler when the fuel is completely burned and the boiler is cooled down to at least +40 °C.

Clean smoke-black and scurf from combustion chambers and flue walls using a scraper

and metal hog. Clean after the doors of the combustion chambers are open and caps of flue upper

openings unscrewed . When finished, check, whether no ashes or smoke-black fell into the ventilator

opening and tightly screw the caps of the flue openings.

Control water pressure in the heating system at least every two weeks. If necessary, fill it

up. If the boiler is not being heated, drain the water off the system when air temperature is below 0 °C!

Emergency extinction of the boiler

If due to any reasons you must immediately extinct the heated boiler, by any means don't

pour water on the kindling wood! The boiler can burst.

It is very convenient to use dry sand for emergency extinction. There should be ~50 kg of

dry sand in the boiler room. Sand not only well isolates burning firewood from the air oxygen but also

cools down the burning zone. Then, when the boiler cools down, sand can be easily cleaned and

removed.

Damage

1. The set temperature

(power) cannot be

reached

2. Smoke breaks through

the doors

3. Ventilator isn't

operating

7. POSSIBLE DAMAGES

Cause

Not enough water in the heating

system;

Thermo regulator or ventilator is

broken;

Bad quality fuel (high moisture

content, very large firewood);

Heating surfaces of the boiler are

very impure;

No traction in the chimney (impure) –

the upper ignition is congested;

Ceramic burner is foul.

Tightening rope is damaged;

Doors are leaky along the whole

perimeter.

No traction in the chimney

Emergency thermostat went off

(switch light of ventilator is off);

Thermo regulator or ventilator is

broken;

Disconnection of electricity supply.

Ways of elimination

Fill up

Replace

Use dry fuel, split firewood

Clean

Replace with a new one

Adjust hinge supports and door

lock (regulated screwing or

unscrewing door hinge or lock

screws)

Clean.

Call representatives of the service

company; turn on after indication of

the causes (see section 5)

Replace

Check electric fuses of the building,

call the electrician