Kohler 36VDC Manuale di istruzioni per l'installazione - Pagina 20
Sfoglia online o scarica il pdf Manuale di istruzioni per l'installazione per Generatore portatile Kohler 36VDC. Kohler 36VDC 44. Dc generator sets
Stampa la pagina
1.9 Engine Starting Battery
!
Sulfuric acid in batteries.
Can cause severe injury or death.
Wear
protective
clothing.
Battery acid may cause
blindness and burn skin.
!
Explosion.
Can cause severe injury or death.
Relays in the battery charger
cause arcs or sparks.
Locate
the
well-ventilated area.
battery
charger
fumes.
Battery electrolyte is a diluted sulfuric acid. Battery acid
can cause severe injury or death. Battery acid can cause
blindness and burn skin. Always wear splashproof safety
goggles, rubber gloves, and boots when servicing the
battery. Do not open a sealed battery or mutilate the battery
case. If battery acid splashes in the eyes or on the skin,
immediately flush the affected area for 15 minutes with large
quantities of clean water. Seek immediate medical aid in the
case of eye contact.
Never add acid to a battery after
placing the battery in service, as this may result in hazardous
spattering of battery acid.
Battery acid cleanup. Battery acid can cause severe
injury or death. Battery acid is electrically conductive and
corrosive. Add 500 g (1 lb.) of bicarbonate of soda (baking
soda) to a container with 4 L (1 gal.) of water and mix the
neutralizing solution. Pour the neutralizing solution on the
spilled battery acid and continue to add the neutralizing
solution to the spilled battery acid until all evidence of a
chemical reaction (foaming) has ceased. Flush the resulting
liquid with water and dry the area.
20
Section 1 Installation
WARNING
goggles
and
WARNING
battery
in
a
Isolate the
from
explosive
Battery gases. Explosion can cause severe injury or
death.
Battery gases can cause an explosion.
smoke or permit flames or sparks to occur near a battery at
any time, particularly when it is charging. Do not dispose of
a battery in a fire. To prevent burns and sparks that could
cause an explosion, avoid touching the battery terminals with
tools or other metal objects.
servicing the equipment. Discharge static electricity from
your body before touching batteries by first touching a
grounded metal surface away from the battery. To avoid
sparks, do not disturb the battery charger connections while
the battery is charging. Always turn the battery charger off
before disconnecting the battery connections. Ventilate the
compartments containing batteries to prevent accumulation
of explosive gases.
Battery short circuits.
injury or death. Short circuits can cause bodily injury and/or
equipment damage.
Disconnect the battery before
generator set installation or maintenance. Remove all
jewelry before servicing the equipment. Use tools with
insulated handles. Remove the negative (–) lead first when
disconnecting the battery. Reconnect the negative (–) lead
last when reconnecting the battery.
negative (–) battery cable to the positive (+) connection
terminal of the starter solenoid.
condition by shorting the terminals together.
Connecting the battery and the battery charger.
Hazardous voltage can cause severe injury or death.
Reconnect the battery correctly, positive to positive and
negative to negative, to avoid electrical shock and damage
to the battery charger and battery(ies). Have a qualified
electrician install the battery(ies).
Use a 12-volt group 51 battery with a minimum rating
of 500 cold cranking amps at 0°F. The generator set
uses a negative ground with a 12-volt engine electrical
system.
See Figure 1-18 for battery connections.
Make sure that the battery is correctly connected and
the terminals are tight.
Note: The generator set will not start and circuit board
damage may occur if the battery is connected in
reverse.
See the dimension drawings in Figure 2-3 through 2-5
for the engine starting battery location behind the
service door on the generator set. Standard battery
cables provide easy connection to the battery.
Do not
Remove all jewelry before
Explosion can cause severe
Never connect the
Do not test the battery
TP-6842 7/15