- ページ 9
実用車 American Sportworks 7151 150ccのPDF オーナーズマニュアル / パーツマニュアルをオンラインで閲覧またはダウンロードできます。American Sportworks 7151 150cc 13 ページ。 Ages 13+ / 39 mph max speed 150cc fun kart
ページを印刷する
SECTION 3
REPLACEMENT PARTS AND SERVICE
Most replacement parts are typically available from your dealer. Because of immediate availability and convenience, it is recommended that replacement
parts be ordered from an authorized dealer. Take this manual and all supplements to the dealer when ordering parts in person.
If replacement parts are not available from a dealer, they may be ordered directly from American Sportworks by contacting ASW at 1-800-643-7332 or
online at www.amsportworks.com. Orders may be subject to a minimum fee. A listing of authorized service center locations in your area is also available
from our Customer Service department.
Record the Vehicle Identification Number (VIN) in the spaces provided at the front of this manual. The VIN can be found on the crossbar, behind the seat.
A. Air Cleaner
(see fig. A1)
This unit is equipped with a paper style air filter element and should be replaced after every 20 hours of
operation (Ref Figure).
NOTE: Operation in unusually dusty conditions may require more frequent replacement.
1)
Remove the air cleaner cover (1) by removing the Phillips head screws.
2)
Clean any excess dirt, oil, or dust from the air cleaner box with a mild detergent and water
solution.
3)
Thoroughly dry the air box
4)
Replace the air cleaner element (2)
5)
Carefully align the gasket between the air box halves during re-assembly
B. Engine Lubrication
You MUST change the oil in the crankcase after the first 5 hours of operating a new engine. The engine oil should then be changed every 20 hours of
use thereafter. This will insure proper lubrication of the internal parts and prevent costly repairs due to excessive wear.
CAUTION
!
This unit has been shipped with special BREAK-IN oil pre-filled in the engine crankcase. This oil MUST
be changed after 5 hours of operation. Replace with SAE 10W40 weight motor oil as described in the
following section.
WARNING
!
THINK
GREEN
a. Remove the drain plug located on the bottom of the right rear side of
engine. Elevating the front of the kart slightly will help drain all of the oil.
b. The oil should be emptied into suitable container for recycling.
c. Remove and clean the oil screen.
d. With the oil completely drained, replace the drain plug and tighten securely.
e. Place the kart back onto a flat surface to level the engine, and Re-fill the
crankcase with 30oz of SAE 10W40 motor oil.
f. Check the oil level using the dipstick attached to the oil plug cap. Be sure to
check the oil level before each use of the kart. Add oil when necessary to keep
the oil level between the bottom of the dipstick and the "O" mark.
NOTE: Oil level should be checked by dipping the oil level stick into the crankcase
WITHOUT screwing the cap in.
5
SERVICE
(see fig. B1)
Used oil MUST be disposed of at a proper collection center
7151 OWNERS MANUAL / ILLUSTRATED PARTS LIST
fig. A1
fig. B1
service
15516R1