- ページ 3

ツール Alemlube HR90080のPDF オーナー技術マニュアルをオンラインで閲覧またはダウンロードできます。Alemlube HR90080 6 ページ。 Single pedestal 3/4" fuel hose reel

ページを印刷する

OWNER'S TECHNICAL MANUAL

OPERATION

1. Pull out the hose slowly to the desired length and release it. The hose may be retracted by a small section

(about 10-15m) and get into a locked status for use.

2. To retract the hose, pull the hose out about 4cm (1.6in) and release it. The hose can be retracted to the hose reel.

3. There is a slow retraction device installed on the hose reel. When the hose is in the retraction state, the slow

retraction device will have a deceleration effect, which can significantly reduce the retraction speed of the hose

(the longer the length of the retracted hose, the more obvious the deceleration effect), and ensure the operation

safety of the hose when it is retracted.

4. Periodically check the hose condition for wear or damage, and check the swivel fitting for leakage.

Replace any worn, damaged, or leaking parts.

Hose Replacement

1. Turn off air supply to reel and carefully release pressure in hose.

2. Securely stabilize the reel by mounting or clamping to work surface.

3. Pull out all the old hose and lock the reel in this position.

Caution: Make sure reel drum is securely locked by letting ratchet teeth engage.

4. Remove the two hose clamps connecting the hose to the reel.

5. Carefully disconnect hose from the swivel joint on the side of the reel and discard old hose.

6. Feed new hose through guide and opening in drum, use sealant and connect to swivel.

Reuse hose clamps on inside and outside of drum flange to reconnect hose.

7. Securely install stopper on other end of hose in the same position as before.

Adjustments can be made later.

SPRING CANISTER WARNING

If the rewind spring fails for any reason:

For safety reasons, Alemlube strongly recommends the replacement of the spring canister be carried out

by a professional mechanic.

LIMITED WARRANTY

1. Alemlube's warranty for this hose reel against defects in material and craftsmanship is for a period of 2 years

from date of purchase.

2. Hose, if supplied with reel, O-rings, plastic rollers and rubber stopper are deemed to be normal wear items;

not warranted.

3. Manufacturer's limited liability is to replace or repair the defective material within the warranty period.

4. The warranty does not cover damage caused by accident, misuse or faulty installation.

5. The reel must be installed and maintained in compliance with the instructions.

NSW/ACT

QLD/PNG

TEL: (02) 9677 1555

TEL: (07) 3204 9166

FAX: (02) 9675 1155

FAX: (07) 3204 1224

Single Pedestal 3/4" Fuel Hose Reel

VIC/TAS

TEL: (03) 8787 8288

FAX: (03) 8787 8266

Visit our website at

www.alemlube.com.au

SA/NT

TEL: (08) 9302 4199

TEL: (08) 8241 7111

FAX: (08) 9303 2095

FAX: (08) 8241 7011

www.alemlube.co.nz

HR90080

TEL: (09) 447 1007

FAX: (09) 447 1008