CombiSteel 7455.1405 사용자 설명서 - 페이지 3
{카테고리_이름} CombiSteel 7455.1405에 대한 사용자 설명서을 온라인으로 검색하거나 PDF를 다운로드하세요. CombiSteel 7455.1405 6 페이지. Dough mixer
페이지 인쇄BM series spiral mixers are a new type of kneader. Both the dough arm and bowl are running to be able to raise the mixing
speed and efficiency greatly. The machines are equipped with a protective cover, are easy to operate and safe. They are good
looking and easy to clean, suitable for mixing flour in hotels, restaurants and public canteens.
Technical specifications
Model
Voltage
7455.1400
~230
7455.1405
~230
Operation and Notes
1.
Set it on a dry horizontal plane (or support), place it firmly.
2.
Before use, ensure that the power supply corresponds to that required by the machine and that the external ground
wire is reliably connected.
3.
Ensure that flour mixing capacity is lower than the max. flour capacity.
4.
Before starting, ensure that the protective cover has been put down.
5.
Do not put hands and hard-things into the bowl while it runs.
6.
Do not hold and drag the belts and chains by hand.
Maintenance
1.
Continuous run time is not too long, keep using the machine.
2.
After use, clean the machine, as to avoid bacteria growth.
3.
The transmission case is packed with special grease that will last for six months of service. To add or replace grease,
it is necessary to remove the upper cover.
Note: Before maintenance, the machine must be cut off from the power supply.
Troubleshooting
Problem
The mixing shaft does not rotate after
being switched on
Square rod trembles
Temperature rise of motor is too high,
low speed
The noise of the transmission case is
loud
The agitator knocks against the bowl
Warning: It cannot be cleaned with water directly.
Frequency
Power
Rating
50Hz
1.1 kW
50Hz
1.5 kW
Probable cause
Electric connectors are loose
Lock bolts are loose
Lack of voltage
Overload
Lubrication is insufficient
Chains are loose
The agitator or bowl is deformed
www.combisteel.com
IP
Bowl
Dough max.
volume
quantity
IPX1
20
6 kg
IPX1
30
12,5 kg
Check the electric circuit, tighten those loose
connectors
Tighten those bolts
Check the supply voltage
Load it less
Add or replace the grease
Tighten the chains
Repair or replace deformed part
Dimension
Net
(a×b×c) mm
weight
675×400×825
85 kg
730x445x860
97 kg
Remedy
3