Decor Star PL-004-SS-TB 설치 지침 매뉴얼 - 페이지 11

{카테고리_이름} Decor Star PL-004-SS-TB에 대한 설치 지침 매뉴얼을 온라인으로 검색하거나 PDF를 다운로드하세요. Decor Star PL-004-SS-TB 12 페이지.

페이지 인쇄

Cleaning The Thermostatic Valve

Before You Begin

•

Read and understand this instruction completely before service the shower panel.

•

Make sure the water supply is shut off to the unit. If necessary, shut off the water to the entire

house.

•

Turn on one of the faucets in the house to relieve the water pressure in the plumbing system.

•

Make sure the service site is clean and free of dust and debris.

Parts Diagram

Fig. B

Thermostatic Valve Cleaning / Replacement Instructions

1. Remove Cap #1 from the Temperature Control Knob #3.

2. Use a small hex wrench, loosen the Setscrew #2 by 2-3 turns. (NOTE: Do not remove the

setscrew completely.)

3. Remove Temperature Control Knob #3.

4. Remove Temperature Limiter #5 by pulling it off the Thermostatic Valve #7.

5. Use a small needle nose pliers remove the brass Valve Retaining Plate #6. See Figure A for

reference.

6. Use a pair of pliers to pull out the Thermostatic Valve #7 for cleaning. (Figure B)

7. Use commercially available hard water scale remover to clean the valve. Dilute the solution as

instructed on the cleaner. Soak the valve for about 5 minutes in the solution and clean it with a soft

brush. (Figure C)

8. Thoroughly rinse the Thermostatic Valve under running warm water. Wash off any cleaning

solution and debris off the Thermostatic Valve. (Figure D)

9. After the cleaning process, follow the above steps in reverse order to assemble the shower panel.

(NOTE: When inserting the thermostatic valve, make sure the marking on the tip of the valve is

pointing up at 12 o'clock position as seen in Figure E)

10. Turn on water supply to the unit and test the system for leak.

Decor Star

Fig. A

1. Cap

2. Setscrew

3. Temperature Control Knob

3-1. Safety Pin

4. Chrome Trim w/ Temperature Scale

Fig. C

3-1

Fig. E

Fig. D

5. Temperature Limit Stop

6. Valve Retaining Plate

7. Thermostatic Valve

8. Setscrew

9. Brass Housing

PL-004-SS-TB Rev. C 022018