Jandy Versa-Plumb CV460 설치 및 운영 매뉴얼 - 페이지 7

{카테고리_이름} Jandy Versa-Plumb CV460에 대한 설치 및 운영 매뉴얼을 온라인으로 검색하거나 PDF를 다운로드하세요. Jandy Versa-Plumb CV460 20 페이지. Cartridge pool filters
Jandy Versa-Plumb CV460에 대해서도 마찬가지입니다: 설치 및 운영 매뉴얼 (20 페이지), 설치 및 운영 매뉴얼 (20 페이지)

페이지 인쇄

# 12x 1" P a n H e a d

S t a i n l e s s S t e e l

S c r e w ( Q t y 8)

A n c h o r

B r a c k e t

( Q t y 4)

F i l t e r T a n k A n c h

o r B r a c k e

Figure 3 .

A nc hor B rac k et I nstallation

Figure 4 .

Pressure G auge/ A ir Release A ssemb ly

nut and into the filter tank. Use the flats

on the tank adapter to tighten. Do not

overtighten.

Place the larger, thinner o-ring onto the

gauge housing. Thread the housing into the

coupler on the tank adapter.

Orient the gauge/air release assembly in the

desired position. Raise and thread the locknut

onto the bottom of the gauge/air release

assembly. Hand tighten the nut only. Using

a wrench to tighten the nut may damage the

nut, gauge or air release assembly.

3.4 Filter Plumbing

This filter operates under pressure. When clamped

properly and operated without air in the water

system, this filter will operate in a safe manner.

If the system can be subjected to higher pressure

than the maximum rating of any component,

install an ASME approved automatic pressure

relief valve or pressure regulator in the circulation

system. Set the relief valve or pressure regulator to

lowest working pressure of any of the components

in the system.

Place the filter on the concrete pad, lined up with

the inlet/outlet pipes (see Figures 5 and 5A).

C artridge Pool Filters - C L and C V S eries Filters

1/ 4" x 2- 1/ 4" S . S . T a p c o n

S c r e w a n d S . S . W a s h e r

D r i l l 5/ 32" H o l e

T a n k B o t t o m

t I n s t a l l a t i o n

H o u s i n g

O - R i n g

T a n k A d a p t e r

T a n k A d a p t e r t o H o u s i n g

Co u p l e r

O - R i n g

# 12x 1" S t a i n l e s s S t e e l P a n

H e a d S c r e w s ( Q t y 2)

D r i l l T w o 3/ 32" H o l e s

T h r o u g h F i l t e r B a s e

M o u n t i n g B r a c k e t

A n c h

o r B r a c k e

t t o P l a t f o r m

To reduce pressure losses, 2" (minimum) piping is

recommended for plumbing the system.

For best efficiency use the fewest possible number

of fittings. This will prevent a restriction in the

water flow.

5.1 The CV model filter comes with a Jandy

Sweep Elbow for this purpose. The sweep

elbow also includes a threaded port and plug

so that a ½" hose bib can be connected for

pressure testing. See Figure 7.

5.2 To install the sweep elbow use the following

instructions:

T o a v o

i d a n e l e c t r i c a

i n s e

r i o u s i n j u r y o r d e a t h , e n s u

p o w e r t o t h e s y s t

i n s p

e c t i n g o r t r o u b l e s h

o r p l u m b i n g t h a t m a y h a v e

d e v i c e

s i n t h e s u

r r o u n d i n g a r e a t o g e t w e t .

F o l l o w a l l f i l t e r m a n u f a c t u r e r ' s

i n s t r u c t i o n s .

a s s e

f i l t e r w h e n t h e r e i s p r e s s u

s y s t

i s a n y p r e s s u

c a

u s e

c a

n c a

i n j u r y o r p r o p e r t y d a m a g e .

Switch off the circuit breaker to the

equipment and open the air relief valve on

top of the filter (leave it open during this

procedure).

If the filter is below pool level, close the suction and

N O T E

return line valves to isolate the filtration system.

Remove the drain plug from the filter. Let the water

drain from the filter.

F i l t e r B a s e

M o u n t i n g T a b

I n s t a l l a t i o n

W A RN I N G

l s h

o c k

h a z a

r d , w h i c h

r e t h a t a l l e l e c t r i c a

e m

i s t u r n e d o f f b e f o r e a p p r o a c h

o o t i n g a n y l e a k i n g v a

c a

u s e

d o t h e r e l e c t r i c a

W A RN I N G

N E V E R a t t e m p t t o

m b l e , d i s a

s s e

m b l e o r a d j u s t

r i z e

e m . S t a r t i n g t h e p u m p w h i l e t h e r e

r i z e

d a i r i n t h e s y s t

t h e f i l t e r l i d t o b e b l o w n o f f , w h i c h

u s e

d e a t h , s e

r i o u s p e r s o

Page 7

3- 1/ 2" T h i c k

( M i n . )

Co n c r e t e P a d

c a

n r e s u

l t

i n g ,

l v e

t h e

d a i r i n t h e

e m

c a

n a l