Kohler Various 서비스 게시판
{카테고리_이름} Kohler Various에 대한 서비스 게시판을 온라인으로 검색하거나 PDF를 다운로드하세요. Kohler Various 3 페이지.
페이지 인쇄
Due to the increase in starter warranty claims we will be requiring some simple testing be performed when
replacing a starter under warranty. Listing a starter as the defective part you will be requested to enter the results
from the test below in the parts information box. By performing these test procedures you will expedite the
warranty claim review on starters. Any starter warranty claim submitted without completing these tests will be
rejected and returned.
This new policy has been put in place and will be enforced beginning April 1, 2011.
Below we have provided the testing procedures and questions that will be required. Also included with each
starter is an installation instruction that outlines the testing procedure.
NOTE: Please perform the following testing as near to the conditions during failure (i.e. in the morning when
cold, a hot restart, or as close to the description of failure provided by the customer).
Explosive Fuel can cause fires
and severe burns.
Do not fill the fuel tank while the
engine is hot or running.
Gasoline is extremely flammable and its vapors can explode if ignited. Store gasoline only in approved containers, in well ventilated,
unoccupied buildings, away from sparks or flames. Do not fill the fuel tank while the engine is hot or running, since spilled fuel
could ignite if it comes in contact with hot parts or sparks from ignition. Do not start the engine near spilled fuel. Never use
gasoline as a cleaning agent.
Electrical Shock can cause injury.
Do not touch wires while engine is
running.
Never touch electrical wires or components while the engine is running. They can be sources of electrical shock.
Before Starting
• Disable ignition system: disconnect the spark plug lead from the spark plug, then ground the spark plug lead
to the engine block using mechanical means. Refer to the correct engine service manual if necessary.
• Battery voltage should be tested and must be at 12.4 VDC or higher. Do not proceed if battery voltage is less
than 12.4 VDC as battery should be charged.
Service
Routing
Manager
Initial Here
PRINTED IN U.S.A.
Service
Bulletin
Starter Warranty Policy
Starter Warranty Test Procedures
WARNING
CAUTION
Sales
Parts
Chief
Manager
Manager
Mechanic
ENGINE DIVISION, KOHLER CO., KOHLER, WISCONSIN 53044
NO.
MODEL
DATE ISSUED
8/10
Mechanic
Mechanic
Mechanic
No. 1
No. 2
No. 3
302
Various
DATE REVISED
(OVER)
Return
Mechanic
No. 4
This To