Acdeos AXS FL 요약된 매뉴얼 - 페이지 12

{카테고리_이름} Acdeos AXS FL에 대한 요약된 매뉴얼을 온라인으로 검색하거나 PDF를 다운로드하세요. Acdeos AXS FL 17 페이지. Fixed step
Acdeos AXS FL에 대해서도 마찬가지입니다: 설치 지침 (7 페이지)

Check that the red LED on the dashboard turns red when the step is out.

Check that the buzzer works while the step is moving in or out. (If not disconnected)

4. SAFETY FUNCTION – Move the step out and try to stop it with your hand. The step should

stop, move back, and come out again. It will try this 3 times, then it will stop. It should go

back in after closing the door.

5. INTERLOCK VEHICLE –Release the vehicle handbrake, then try to operate the step. It

should not be possible to operate it. (unless the handbrake interlock is not installed)

6.2.3

Yearly maintenance / normal maintenance

A thorough maintenance check should be done once every year or at least every 10.000

cycles.

We recommend reduce the maintenance period to 6 months when the step is used in hard

conditions with much snow / ice / mud / gravel etc,

Normal maintenance:

Bring the step in the out position. Remove the bottom plate screws. Remove the bottom plate

by lifting it with a flat head screwdriver.

•

Check all moving parts like, arm gears, push

rods and wheels for excessive play. If there is

excessive play on moving parts it is

recommended to replace these parts.

•

Check the adjustment of the in and out switch.

•

Check wires and electrical connections for

possible failures.

•

Clean all parts

•

Grease moving parts with MOTIP White

PTFE grease or normal bearing grease.

Close the bottom plate.

With step still in out position remove ty-rap at the rear of the

step from both rubber end caps.

Spray a good grease in the tube or use normal bearing

grease with a long brush. This is the most important part

of the maintenance.

Close rubber caps again and fit with a new Tie-wrap

We strongly recommend MOTIP White PTFE grease part

nr 090204 for all parts in the step, do not use WD40 or

silicon

Other similar PTFE grease sprays can also be used.

This spray is also available at Acdeos under part number

S150 310

sprays