DISCOVER 44-24-2800 운영 매뉴얼 - 페이지 9

{카테고리_이름} DISCOVER 44-24-2800에 대한 운영 매뉴얼을 온라인으로 검색하거나 PDF를 다운로드하세요. DISCOVER 44-24-2800 13 페이지. Advanced energy lithium ion battery

페이지 인쇄

1. Protection and Faults

6.5 Storage

Systems should be stored out of direct sunlight under the following temperature conditions:

Systems should be put into storage at 80% SOC and checked monthly to ensure SOC does not fall below 20%.

At 20% SOC the battery will self discharge in approximately 2 months.

7. Protection & Faults

• BMS generates faults when maximum operating limits are reached.

• BMS sounds a buzzer when fault limits are triggered.

• BMS monitors the following information for faults and warning:

1. Cell module voltage

2. Battery current

3. Battery temperature

High Temperature

Low Temperature

High Voltage

Low Voltage

Over Current

Low SOC

Inaccurate SOC displayed by

Power Conversion system

Minimum Storage Temperature

Maximum Storage Temperature

▲ CAUTION!

Do not store a discharged battery. Recharge battery after

every use. Batteries that have self-discharged to a severely

discharge state are not recoverable.

▲ NOTE!

Refer to device technical specification tables at the end of

this manual for Fault Limits.

CORRECTIVE ACTIONS

• Stop discharge or charge

• Leave the battery to cool

• Stop discharge or charge

• If charging stop the charge

• Confirm proper charge algorithm is being used

• Do not discharge the battery - if any discharge current is detected, this will force the

battery into Low Voltage Fault

• Charge the battery in Low Voltage Recovery - if no charge current is detected within 2

minutes the BMS will set the battery to OFF

• Reduce current

• Stop discharge

• Charge the battery

• Battery voltage based SOC calculations provided by Power Conversion systems do

not work properly with Lithium battery voltage.

• Use a Discover CAN Bus Battery Discharge Indicator (p/n 950-0005, 950-0006,

950-0007) to display accurate SOC. To communicate accurate SOC in a closed loop

Power Conversion system use a Discover LYNK Communications Gateway device

(p/n 950-0015)

-20°C / -4°F

45°C / 113°F