DIVERSIFIED SJP-008 매뉴얼 - 페이지 3

{카테고리_이름} DIVERSIFIED SJP-008에 대한 매뉴얼을 온라인으로 검색하거나 PDF를 다운로드하세요. DIVERSIFIED SJP-008 8 페이지.

페이지 인쇄

Safe Job Procedure –

Preparation: Safety Specialist

LADDER MAINTENANCE:



Aluminium, fiberglass and metal ladders should be cleaned with soap and water, as needed.



Wooden ladders should be cleaned with a mild soap and water, and then dried.

Note: Wooden ladders that have been painted shall be removed from service.

STORAGE AND MOVING LADDERS:



Step ladders must always be secured to a wall or affixed structure, whether they are stored horizontally

or vertically. Horizontal storage either on the floor or hung on the wall must be supported at 4 to 5 foot

intervals; this is the same requirement for vertical storage. Step stools may be collapsed when not in

use.



Ladders should not be stored in areas where there is excessive heat or dampness. Also, it is best to

store ladders away from high traffic areas - people.



When moving a ladder, collapse the ladder, hold the middle side rail and tip slightly forward, watching

for overhead hazards and hazards at both ends

LADDER PRECAUTIONS:

To avoid accidents with portable ladders:

 Select the right ladder for the job situation; use the ladder as it was designed to be used; do not

overload a ladder (ie. do not put more weight on a ladder than it is designed to hold)

 Step ladders cannot be used as straight ladders

 Step ladders are designed for one person only

 Before use, inspect the condition of the ladder; do not use a ladder with damaged parts that affect the

strength of the ladder; do not alter the structure of the ladder

 Before use, inspect the job-site for overhead wires and obstructions

 Before use ensure the stability of the base of the ladder; base to be placed on a level, non-slippery solid

surface. Remove material and debris away from the base of the ladder

 Wooden ladders should not be painted

 Avoid pushing or pulling step ladders from the side

 Do not overload a ladder beyond its weight capacity

 Do not leave ladders that are set-up unattended

 Do not climb the back of a step ladder

 Clean the soles of your footwear before climbing the ladder

 Do not work on ladders when feeling weak, sick, or dizzy or when taking medication that may cause

drowsiness

 Do not work on ladders covered with snow, ice, or other slippery materials

 Do not work on ladders in bad weather or high winds

 Do not use ladders, boxes, barrels, or other makeshift materials to raise your work height

 Step ladders must be tall enough to perform the necessary work

NOTE:



All PPE must be inspected prior to use.



All equipment must be inspected prior to use.

Controlled by:

Safety Specialist

February 21, 2019

Portable Ladders

Approval Authority: Senior Management

Revised:

Approved by:

Senior Management

Industry Type:

Initial Issue Date:

Revision No:

Issuing Dept: Safety

P:\Corporate\Safety Docs\Safe Job Procedures (SJP's)

All

August 3, 2018

SJP-008

Path:

Page 3 of 8