Altrad Belle RPC 45 운영자 매뉴얼 - 페이지 8
{카테고리_이름} Altrad Belle RPC 45에 대한 운영자 매뉴얼을 온라인으로 검색하거나 PDF를 다운로드하세요. Altrad Belle RPC 45 13 페이지.
페이지 인쇄GB
For your own personal protection and for the safety of those around you, please read and ensure you fully understand the following
safety information. It is the responsibility of the operator to ensure that he/she fully understands how to operate this equipment safely. If
you are unsure about the safe and correct use of the 'RPC', consult your supervisor or Altrad Belle.
CAUTION
•
This equipment is heavy and must not be lifted single-handedly, either GET HELP or use suitable lifting equipment.
•
Cordon off the work area and keep members of the public and unauthorised personnel at a safe distance.
•
Personal Protective Equipment (PPE) must be worn by the operator whenever this equipment is being used (see Health & Safety).
•
Make sure you know how to safely switch this machine OFF before you switch it ON in case you get into dif culty.
•
Always switch OFF the engine before transporting, moving it around the site or servicing it.
•
During use the engine becomes very hot, allow the engine to cool before touching it. Never leave the engine running and
unattended.
•
Never remove or tamper with any guards tted, they are there for your protection. Always check guards for condition and security,
if any are damaged or missing, DO NOT USE THE COMPACTOR until the guard has been replaced or repaired.
•
Do not operate the Compactor when you are ill, feeling tired, or when under the in uence of alcohol or drugs.
CAUTION
Fuel Safety.
•
Before refuelling, switch off the engine and allow it to cool.
•
When refuelling, DO NOT smoke or allow naked ames in the area.
•
Spilt fuel must be made safe immediately, using sand. If fuel is spilt on your clothes, change them.
•
Store fuel in an approved, purpose made container away from heat and ignition sources.
GB
Vibration
Some vibration from the compaction operation is transmitted through the handle to the operator's hands. The Altrad Belle RPC range
has been speci cally designed to reduce hand/arm vibration levels. Refer to speci cations & technical data for vibration levels and us-
age times (recommended maximum daily exposure time). DO NOT exceed the maximum usage times.
PPE (Personal Protective Equipment)
Suitable PPE must be worn when using this equipment i.e. Safety Goggles, Gloves, Ear Defenders, Dust Mask and Steel Toe capped
footwear. Wear clothing suitable for the work you are doing. Tie back long hair and remove any jewellery which may catch in the
equipment's moving parts. Always protect skin from contact with concrete.
Dust
The compacting process will occasionally produce dust, which may be hazardous to your health. Always wear a mask that is suited to
the type of dust being produced.
Fuel
Do not ingest fuel or inhale fuel vapours and avoid contact with your skin. Wash fuel splashes immediately. If you get fuel in your eyes,
irrigate with copious amounts of water and seek medical attention as soon as possible.
Exhaust Fumes
Do not operate the compactor indoors or in a con ned space, make sure the work area is adequately ventilated.
WARNING
GB
Pre start-up inspection
The following Pre-start-up inspection must be performed before the start of each work session or after every four hours of use, which-
ever is rst. Please refer to the service section for detailed guidance. If any fault is discovered, the compactor must not be used until
the fault is recti ed.
1. Thoroughly inspect the compactor for signs of damage. Check components are present and secure. Pay special attention to the
belt guard.
2. Check the engine oil and hydraulic oil level and top up as necessary.
3. Check the engine fuel level and top up as necessary.
4. Check for fuel, oil and hydraulic leaks.
General Safety
Improper maintenance can be hazardous. Read and Understand this section before you perform any
maintenance, service or repairs.
Fuel is ammable. It may cause injury and property damage. Shut down the engine, extinguish all open
ames and do not smoke while lling the fuel tank. Always wipe up any spilled fuel.
Health & Safety
The exhaust fumes produced by this equipment are highly toxic and can kill!
Pre-Start Checks
8