Doka 588676000 원본 사용 설명서 - 페이지 11
{카테고리_이름} Doka 588676000에 대한 원본 사용 설명서을 온라인으로 검색하거나 PDF를 다운로드하세요. Doka 588676000 18 페이지.
페이지 인쇄Original Operating Instructions Framax stripping corner I hydraulic
Boundary conditions for use
NOTICE
▪
The Hydraulic unit Framax V4 has sufficient
oil capacity for extending 6 stripping cylin-
ders.
▪
The hydraulic unit Framax V4 is suitable for
deployment at outside temperatures of
between -5° C and +55° C.
It is not permissible to put the unit into ser-
vice at temperatures of below -5° C, as the
hydraulic oil would be too viscous.
Deployment in low ambient temperatures:
➤
Store the unit in a warm environment.
Deployment in high ambient temperatures:
➤
Store the unit where it is protected from the direct
rays of the sun.
Equipment components
As-delivered condition:
▪
Doka supplies the unit in ready-for-use condition.
- cleaned reservoir
- clean hydraulic oil
- valid inspection sticker
Note:
The following are kept in the documents container:
▪
Hexagon-socket screw key (width-across 12 mm)
▪
3 cylinder screws M10x20 10.9 ISO 4762
As spares for the drive hexagon socket (width-
across 8 mm).
▪
2 bits, hexagon socket (width-across 8 mm), min. 30
mm long
▪
Operating Instructions
▪
Hydraulic circuit diagram
Leakage test
Hydraulic units are subjected to considerable stresses
and strains - e.g. vibrations, temperature fluctuations
and high pressures.
➤
Ensure scrupulous cleanliness during operation, so
that you can detect leaks at an early stage and rule
out possible sources of errors.
This inspection should focus on the:
▪
Flatface plug-in connectors
▪
threaded joints
▪
joining surfaces between the individual
valve components
▪
oil reservoir
999239002 - 07/2018
Installation of the hydraulics
➤
Swivel the footplate flat to the ground.
➤
Route the Pair of hydraulic hoses from the stripping
cylinder to the Hydraulic unit Framax V4 and connect
the hoses.
A
9239-204-01
A Pair of hydraulic hoses
B Footplate
➤
Temporarily stow pairs of hydraulic hoses that are
not in use in the parking positions inside the Hydrau-
lic unit Framax V4.
A Pair of hydraulic hoses
C Parking position, Pair of hydraulic hoses for Framax stripping
corner I
B
C
C
A
9239-207-01
11