Astria Polaris42ZEP Installation Instructions Manual - Page 10

Browse online or download pdf Installation Instructions Manual for Outdoor Fireplace Astria Polaris42ZEP. Astria Polaris42ZEP 16 pages. Outdoor decorative gas fireplace

Print Page

FIELD WIRING

CAUTION: Label all wires prior to disconnec-

tion when servicing controls. Wiring errors

can cause improper and dangerous operation.

Verify proper operation after servicing.

Refer to Figure 10 for the wiring schematic

for these fireplaces.

This fireplace is completely wired internally.

On the right hand side of the fireplace, at the

rear, are four (4) wires required to connect the

Battery and switch for operation.

Two brown wires are for the connection of the

switch. These are labeled SW and SW. A black

and red pair are for connection to the battery

pack. These are labeled (+) and (–).

These wires are for low voltage current. An

electrical box has been provided to contain both

the switch and battery pack. Mount the box in

an appropriate location within the length of the

wiring provided. Feed all four wires through one

of the lower inlets to the box. Connect the switch

wires to the switch and the corresponding (+),

(–) to the battery holder.

Install two D-cell batteries (not provided) and

test the switch before closing the switch box

(refer to Figure 11). The igniter should spark

to the pilot when the switch is on.

ELECTRONIC IGNITION WIRING DIAGRAM

NOTES:

1. If any of the original wire as supplied must be replaced, use Type AWM 105°C - 18 gage wire ONLY.

2. Electrical Rating: 3V DC.

CAUTION: label all wires prior to disconnection when servicing controls. Wiring errors can cause

improper and dangerous operation. Verify proper operation after servicing.

WALL SWITCH BOX

WEATHER

SEAL

COVER

D-CELL BATTERIES

REMOTE WALL SWITCH

BLACK

WALL SWITCH BOX

BATTERY

REMOTE

WALL

SWITCH

RED

BROWN

Figure 1

Weather Seal

Cover

Switch

Figure 1

NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.

PILOT BURNER

IGNITER-SENSOR

ASSEMBLY

IGNITER MODULE - 3V

BLACK

SPARK WIRE CABLE

BLACK

PILOT SENSOR CABLE

ELECTRONIC GAS CONTROL VALVE - DEXEN

ORANGE

(THTP)

(TP)

BLACK

HIGH LIMIT

(TH)

SWITCH

GREEN

BLACK JUMPER

Schematic Representation Only

UMBILICAL CORD (9 Feet)

Orient Batteries Vertically

To Fit Within Box

IGNITER

FLAME

SENSOR

ROD

PILOT TUBE