Century Hearth FW270007NB Manual - Page 2

Browse online or download pdf Manual for Wood stove Century Hearth FW270007NB. Century Hearth FW270007NB 2 pages.

Print Page
This manual describes the installation and operation of the Model FW270007NB non-catalytic wood
heater. This heater meets US Environmental Protection Agency's emission limits for wood heaters.
Under specific conditions this heater has been shown to deliver heat at rates ranging from 10,370 to
29,301 BTU per hour.
Model No. FW270007NB
This unit has been listed by Warnock Hersey
Limited to meet or exceed ULC S-627
Canada and UL 1482 U.S.
Contact your local building inspector
prior to installation.
A permit maybe required in your area.
2ft(635mm) HIGHER THAN
NEAREST POINT OF
3FT(1M) MIN
FROM ROOF
ROOF WITHIN 10ft(3M)
PENETRATION
MINIMUM OVERALL
G
HEIGHT FROM FLOOR
15FT(5M)
Unit must be placed on a noncombustible floor protection equivalent to 3/8" millboard.
Floor protector must have min. R value of .893
Consult your local building authorities for further information.
HANDLE
Twist spring handle
SPRING
in counter
clockwise motion while pushing on to handle;
spring handle will "thread" down to desired
location.
Desired Burn Setting
Low
Med / Low
Med / High
High
**Performance may vary depending on actual home operating conditions
MADE IN CANADA BY CFM Corporation, 410 Admiral Boulevard, Mississauga, ON L5T 2N6
NOTE: Retain this sheet for future reference
6" Flue Required
Figure A: Clearance from combustible constructions
A minimum clearance of 18" (457mm) to the chimney connector
may be required by the authority having jurisdiction.
From Heater
From Chimney Connector
A
Sidewall..........17-1/2" (444 mm)
D
Sidewall.................28"
B
Backwall...............13" (330 mm)
E
Backwall................15-1/2" (394 mm)
C
Corner...................11" (279 mm)
F
Corner....................22"
G
Ceiling....................54-1/2" (1384 mm)
BACK WALL
B
E
8"(203mm)
A
D
*16
**18
C
8"(203mm)
8"(203mm)
Figure "A"
*16"(406mm) U.S.A.
**18"(457mm) Canada
CAUTION: Do not open fire-door to a point where it
would be in contact with the combustible sidewall.
BE SURE TO INSTALL TWO
FULL BRICKS (S16040) IN
BAFFLE AS SHOWN
OPTIONAL FAN
An optional heat exchange blower is available for this
2 FULL BRICKS
wood burning appliance. To order please see the local
dealer where you purchased your appliance.
BAFFLE ASSEMBLY
CAUTION: BRICK FOR ASH DRAWER
MUST BE INSTALLED BEFORE
OPERATION OF WOOD HEATER
Inlet Air Control Settings
Inlet Air Setting
**Approx. BTU Output
Closed Fully
10,370
¼ Open
12,420
¾ Open
15,676
Fully Open
29,301
800-668-5323
Part No 90000159 Rev 01
1
1
10
11
(711 mm)
15
(559 mm)
13
BACK WALL
12
C
F
12
12
F
Disposition Des Briques
Diseño De Colocación De Los Ladrillos
Complete Brick pack part number - S16054 & S16039
ITEM NO.
NO.
LEYENDA NO.
1
DOOR ASSEMBLY
1
DOOR - NO GLASS
2&3
GLASS AND GASKET
3
1/8" GLASS GASKET
4
5/8" DOOR GASKET
5
SPRING HANDLE
AIR CONTROL SPRING HANDLE
6
7
GLASS CLIP
8
GLASS CLIP
9
10
11
12
FIREBRICK LT 9"x4-7/16"x1-1/4"
FIREBRICK LT 7-1/4"x4-7/16"x1-1/4"
13
14
FIREBRICK LT 4-1/2"x4-7/16"x1-1/4"
FIREBRICK LT - ANGLED
15
FIREBRICK LT 4-7/16"x2-3/4"x1-1/4"
16
17
FIREBRICK FOR ASH DRAWER
18
ASH DRAWER ASSEMBLY
19
NICKEL BODY TRIM
20
NICKEL ASH FENDER TRIM
www.cfmcorp.com
5
3
2
15
13
13
13
19
12
16
12
12
12
20
17
12
14
Brick Pattern
PARTS LIST
LISTE DES PIÉCES
DESCRIPTION
DESCRIPTION
PORTE MONTÉE
PORTE - SANS LA VITRE
VITRE DE JOINT D'ÉTANCHEITÉ
JOINT DE LA VITRE 1/8po
JOINT DE LA PORTE 5/8po
POIGNÉE À RESSORT
POIGNÉE POUR L'ADMISSION D'AIR
FERRURE POUR LA VITRE
FERRURE POUR LA VITRE
SCREW
VIS
HINGE PIN
GOUPILLE DE CHARNIÈRE
PUSH NUT
ÉCROU À RESSORT
BRIQUE 9"x4-7/16"x1-1/4"
BRIQUE 7-1/4"x4-7/16"x1-1/4"
BRIQUE 4-1/2"x4-7/16"x1-1/4"
BRIQUE - COUPLÉE EN ANGLE
BRIQUE 4-7/16"x2-3/4"x1-1/4"
BRIQUE POUR LE CENDRIER
L'ASSEMBLEE DE TROIR DE CENDRE
GARANTURE DU BOÎTIER EN NICKEL
GARANTURE DU GARDE-FEU EN NICKEL
7
4
9
8
6
18
QTY
PART NO.
LISTA DE PIEZAS
QTÉE
NO.de PC
CANT. ART NO.
DESCRIPCIÓN
UNIDAD DE PUERTA
1
S31139
UNIDAD DE PUERTO SIN VIDRIO
1
S41091
VIDRIO Y EMPAQUETADURA
1
S31141
4.3'
S15001
EMPAQUETADURA DE 1/8" PARA EL VIDRO
EMPAQUETADURA DE 5/8" PARA LA PUERTA
5.1'
S15011
MANGO CON RESORTE
1
90000069
1
MANGO CON RESORTE PARA EL REGULADOR DEL AIRE
90000070
PRESILLA PARA EL VIDRIO
2
S37018
PRESILLA PARA EL VIDRIO
1
S37026
TORNILLO
7
S11086
2
PASADOR DE BISAGRA
S11005
2
UNIDAD DEL DEFLECTOR
S11090
12
S16040
LADRILLO REFRACTARIO LT 9"x4-7/16"x1-1/4"
4
S16043
LADRILLO REFRACTARIO LT 7-1/4"x4-7/16"x1-1/4"
LADRILLO REFRACTARIO LT 4-1/2"x4-7/16"x1-1/4"
1
S16046
2
S16042
LADRILLO REFRACTARIO LT - ANGULADO
1
LADRILLO REFRACTARIO LT 4-7/16"x2-3/4"x1-1/4"
S16224
1
LADRILLO PARA DEPÓSITO DE CENIZAS
S16214
1
90000110
ASAMBLEA DE CAJON DE CENIZA
MOLURA DE NÍQUEL PARAEL CUEPO DEL CALEFACTOR
1
90000112
90000113
MOLURA DE NÍQUEL DEL PROTECTOR CONTRA LA CENIZA
1