Gardena 884 Operating Instructions Manual - Page 4
Browse online or download pdf Operating Instructions Manual for Paint Sprayer Gardena 884. Gardena 884 6 pages. Backpack sprayer 12
Also for Gardena 884: Operating Instructions Manual (9 pages), Operating Instructions Manual (9 pages), Operating Instructions Manual (10 pages)
Print Page
G
Spraying :
1. Strap the Backpack Sprayer to your back.
2. Adjust the length of the carrying
straps
adjusters
The stitched end of the carrying
strap is threaded through the strap
adjusters
H
3. Press down the pump lever
until it becomes more difficult to press the lever and you feel
resistance.
4
4. Press the button
The Backpack Sprayer starts spraying.
5. Release the button
The Backpack Sprayer stops spraying.
Adjusting the spray lance :
1. Loosen the union nut
J I
2. Pull out the spray lance
3. Tighten the union nut
Adjusting the spray jet :
You can adjust the spray jet from full jet (nozzle open) to a
fine mist (nozzle closed).
K
v Open or close the nozzle
required.
5. Maintenance
Cleaning the
You must clean your Backpack Sprayer after each use.
Backpack Sprayer :
1. Press the button
pressure through the spray lance.
2. Unscrew tank cap
ly clean the area around the thread and thread O-ring
3. Clean the inlet filter
H
4. Empty the tank and fill with clean water (with detergent added
to the water if necessary).
5. Spray the water out of the Backpack Sprayer until the tank
G
is empty.
L
This cleans the nozzle and valves.
6. Leave the Backpack Sprayer open and allow it to dry.
M
Do not dispose of residual products by pouring them into the
sewerage system. Please contact your local disposal centre
and ask about proper disposal of the products you have used.
Thorough inspection :
We recommend that you have your Backpack Sprayer thorough-
ly inspected (preferably at a GARDENA Service Centre) after
using it for 5 years.
12
7
1
as required using the strap
7
.
7
at the factory.
4
repeatedly (approx. 7 - 9 times)
H
on the sprayer handle.
H
on the sprayer handle.
I
.
J
to the desired length.
I
again.
K
to adjust the spray jet as
H
on the sprayer handle and release the
G
. If the outside of the cap is dirty, thorough-
M
G
and tank cap
in clean water.
6. Trouble-Shooting
1
Clean the filter
in the sprayer handle :
A
Cleaning the pump :
N
O
G
Q
S
P
R
Fault
L
.
Pump does not provide
pressure.
Backpack Sprayer does not
spray although there is
sufficient pressure or
sprays with poor spray jet.
Tank is difficult to open.
If you have any other problems with your Backpack Sprayer please contact GARDENA Customer
Service.
B
1. Unscrew the union nut
and pull the hose
A
out of the sprayer handle
D
2. Rinse the filter
under running water.
3. Reattach the sprayer handle (see 3. Assembly "Attaching the
sprayer handle to the hose").
D
C
B
If the pump does not provide pressure after cleaning your Back-
pack Sprayer you must also clean the pump.
1. Push out the locking ring
N
O
and pull the joint rod
out of the pump
F
P
2. Unscrew the union ring
and pull out the pump
S
3. Inspect the pump O-ring
sary.
4. Pull out the inner part of the pump
5. Clean all pump parts and gaskets with water (and detergent).
6. Reassemble the pump in the reverse order.
When assembling the pump ensure that the pump gaskets are
seated properly after installation and are not squashed.
Possible Cause
Valve in the tank cap blocked.
Hose connections at the
pump and sprayer handle
are leaking.
Q
Pump O-ring
leaking at the
pump.
Nozzle blocked.
D
Filter
in sprayer handle
blocked.
Pressure in tank too low
because the valve in the tank
G
cap
is blocked.
G
C
D
with filter
.
(using a screwdriver, for example)
F
.
F
.
and install a new O-ring if neces-
R
S
and the gasket
.
Remedy
v Clean the tank cap.
v Tighten the hose connec-
tions at the pump and
sprayer handle.
v Clean the pump and
Q
check the pump O-ring
at the pump. Install a new
O-ring if necessary.
v Clean the nozzle.
v Clean the filter in the
sprayer handle.
G
v Clean the tank cap
.
13