Kohler COMMAND CH15 Owner's Manual - Page 16

Browse online or download pdf Owner's Manual for Engine Kohler COMMAND CH15. Kohler COMMAND CH15 17 pages. Horizontal crankshaft
Also for Kohler COMMAND CH15: Owner's Manual (17 pages)

Print Page
Kohler COMMAND CH15 Owner's Manual
(c)
For warranty repairs, the engine must be presented to a Kohler Co. service center as soon as a problem exists. Call 1-800-544-2444, or access
our web site at: www.kohlerengines.com for the names of the nearest service centers. The warranty repairs should be completed in a reasonable
amount of time, not to exceed 30 days.
If you have any questions regarding warranty rights and responsibilities, you should contact Kohler Co. at 1-920-457-4441 and ask for an Engine
Service representative.
COVERAGE
Kohler Co. warrants to the ultimate purchaser and each subsequent purchaser that the engine will be designed, built and equipped, at the time of sale, to
meet all applicable regulations. Kohler Co. also warrants to the initial purchaser and each subsequent purchaser, that the engine is free from defects in
materials and workmanship which cause the engine to fail to conform with applicable regulations for a period of two years.
Engines produced in 2006 or later are warranted for two years in California. For 1997 and later model years, EPA requires manufacturers to warrant
engines for two years in all other states. These warranty periods will begin on the date the engine is purchased by the initial purchaser. If any emission
related part on the engine is defective, the part will be replaced by Kohler Co. at no cost to the owner. Kohler Co. is liable for damages to other engine
components caused by the failure of a warranted part still under warranty.
Kohler Co. shall remedy warranty defects at any authorized Kohler Co. engine dealer or warranty station. Warranty repair work done at an authorized
dealer or warranty station shall be free of charge to the owner if such work determines that a warranted part is defective.
Listed below are the parts covered by the Federal and California Emission Control Systems Warranty. Some parts listed below may require scheduled
maintenance and are warranted up to the first scheduled replacement point for that part. The warranted parts are to the extent they were present in the
engine purchased:
•
Oxygen sensor (if equipped)
•
Intake manifold (if equipped)
•
Exhaust manifold (if equipped)
•
Catalytic muffler (if equipped)
•
Thermal reactor muffler (if equipped)
•
Fuel lines, fuel line fittings and clamps (if equipped)
•
Spark advance module (if equipped)
•
Crankcase breather
•
Air Injection System (if equipped)
- Air pump or pulse valve assembly (if equipped)
- Control/distribution valve (if equipped)
- Distribution manifold (if equipped)
- Air hoses (if equipped)
- Vacuum lines (if equipped)
LIMITATIONS
This Emission Control Systems Warranty shall not cover any of the following:
(a)
repair or replacement required because of misuse or neglect, improper maintenance, repairs improperly performed or replacements not conforming
to Kohler Co. specifications that adversely affect performance and/or durability and alterations or modifications not recommended or approved in
writing by Kohler Co.,
(b)
replacement of parts and other services and adjustments necessary for required maintenance at and after the first scheduled replacement point,
(c)
consequential damages such as loss of time, inconvenience, loss of use of the engine or equipment, etc.,
(d)
diagnosis and inspection fees that do not result in eligible warranty service being performed, and
(e)
any add-on or modified part, or malfunction of authorized parts due to the use of add-on or modified parts.
MAINTENANCE AND REPAIR REQUIREMENTS
The owner is responsible for the proper use and maintenance of the engine. Kohler Co. recommends that all receipts and records covering the
performance of regular maintenance be retained in case questions arise. If the engine is resold during the warranty period, the maintenance records
should be transferred to each subsequent owner. Kohler Co. reserves the right to deny warranty coverage if the engine has not been properly
maintained; however, Kohler Co. may not deny warranty repairs solely because of the lack of repair maintenance or failure to keep maintenance records.
Normal maintenance, replacement or repair of emission control devices and systems may be performed by any repair establishment or individual;
however, warranty repairs must be performed by a Kohler authorized service center. Any replacement part or service that is equivalent in
performance and durability may be used in non-warranty maintenance or repairs, and shall not reduce the warranty obligations of the engine
manufacturer.
FOR SALES AND SERVICE INFORMATION
IN U.S. AND CANADA, CALL 1-800-544-2444
KohlerEngines.com
ENGINE DIVISION, KOHLER CO., KOHLER, WISCONSIN 53044
•
Ignition module(s) with high tension lead
•
Gaseous fuel regulator (if equipped)
•
Electronic control unit (if equipped)
•
Carburetor or fuel injection system
•
Fuel metering valve (if equipped)
•
Air filter, fuel filter, and spark plugs (only
to first scheduled replacement point)
•
Evaporative System (if equipped)
- Canister (if equipped)
- Canister filter (if equipped)
- Vapor hose (if equipped)
- Orifice connector (if equipped)
- Fuel tank (if equipped)
- Fuel cap (if equipped)
- Primer bulb canister (if equipped)
FORM NO.: 12 590 02-B
ISSUED:
11/04
REVISED:
12/07
LITHO IN U.S.A.