Kohler Confidant ZT740 Owner's Manual - Page 4
Browse online or download pdf Owner's Manual for Engine Kohler Confidant ZT740. Kohler Confidant ZT740 24 pages. Vertical shaft
Also for Kohler Confidant ZT740: Owner's Manual (8 pages)
Print Page
Starting
Carbon Monoxide can cause
severe nausea, fainting or death.
Avoid inhaling exhaust fumes.
Never run engine indoors or in
enclosed spaces.
Engine exhaust gases contain poisonous
carbon monoxide. Carbon monoxide is
odorless, colorless, and can cause death if
inhaled.
Rotating Parts can cause severe
injury.
Stay away while engine is in
operation.
Keep hands, feet, hair, and clothing away
from all moving parts to prevent injury. Never
operate engine with covers, shrouds, or
guards removed.
NOTE: Extend starter cord periodically to
check its condition. If cord is frayed
have it replaced immediately by a
Kohler authorized dealer.
NOTE: If using retractable start, slowly pull
starter handle until just past
compression-STOP! Return starter
handle; fi rmly pull straight out to avoid
excessive rope wear from starter rope
guide.
Standard Choke System
● Above 32°F (0°C)
Refer to operating instructions of equipment
this engine powers for specifi c starting
instructions.
● 32°F (0°C) and Below
1. Refer to operating instructions of equipment
this engine powers for specifi c starting
instructions.
2. Refer to Cold Weather Starting Hints within
this manual.
eChoke
TM
● Above 32°F (0°C)
1. This feature will automatically make system
adjustments to engine on start up with
throttle in any position.
2. If engine does not start on fi rst attempt, wait
3-5 seconds (do not turn key to OFF
position) and try again. If no start after third
attempt, wait 1 minute and try again.
4
WARNING
WARNING
KohlerEngines.com
3. If engine does not start consistently by fi fth
attempt, turn key to OFF position, pause
briefl y, turn key to RUN position, pause
briefl y again and then turn key to START
position, attempting to start engine. If engine
still does not start, consult Kohler authorized
dealer for assistance.
● 32°F (0°C) and Below
1. This feature will automatically make system
adjustments to engine on start up with
throttle in any position. Winter blend fuel is
recommended.
2. If engine does not start on fi rst attempt, wait
3-5 seconds (do not turn key to OFF
position) and try again. If no start after third
attempt, wait 1 minute and try again.
3. If engine does not start consistently by fi fth
attempt, turn key to OFF position, pause
briefl y, turn key to RUN position, pause
briefl y again and then turn key to START
position, attempting to start engine. If engine
still does not start, consult Kohler authorized
dealer for assistance.
Cold Weather Starting Hints
1. Use proper oil for temperature expected.
2. Disengage all possible external loads.
3. Use fresh winter grade fuel. Winter grade
fuel has higher volatility to improve starting.
4. Make sure battery has a full charge.
Stopping
1. If possible, remove load by disengaging all
PTO driven attachments.
2. Position throttle control between half and full
throttle; stop engine.
3. Do not allow engine/application to be left
unattended with key ON (RUN position) for
long periods (30 minutes or longer). If left in
such a condition, operator must turn key
completely OFF before attempting a restart
to reset system.
Angle of Operation
Refer to operating instructions of equipment
this engine powers. Do not operate this engine
exceeding maximum angle of operation; see
specifi cation table. Engine damage could result
from insuffi cient lubrication.
Engine Speed
NOTE: Do not tamper with governor setting to
increase maximum engine speed.
Overspeed is hazardous and will void
warranty.
16 590 05 Rev. A