Aqua Creek Products F-MTY400-T Manual - Page 11

Browse online or download pdf Manual for Lighting Equipment Aqua Creek Products F-MTY400-T. Aqua Creek Products F-MTY400-T 13 pages.

Print Page

1. ELECTRONICS INSPECTION

Most electronic issues are due to pool electrical connections and/or a defective battery. Always

remove the battery and place it on the charger when the lift is not in use. NOTE: Even if your

lift is equipped with a solare charger, it is a good idea to place the battery on the wall charger

periodically or during extended periods of non-use or storage. Before testing the battery, charge

overnight. A voltage meter is required for this section and a known GOOD handset controller is helpful.

An Aqua Creek electronics test light is also highly recommended (order item F-01TL). Make comments

and/or recommendations in the notes area below each section.

INSPECTION ITEM

Battery contact points are free of damage and/or corrosion.

Dielectric grease is present on all contact points to prevent

corrosion. ALWAYS STORE THE BATTERY ON THE CHARGER

WHEN LIFT IS NOT IN USE!

Battery level indicator (if equipped) on control box is functioning

properly when the battery is installed on lift.

Using the voltage meter check the voltage on the battery. A good

battery should read between 24v and 28v DC. Note: Vito

batteries will require a test cord. (F-VTC002)

Using the test light, confirm continuity through the control box by

plugging the light into the control box in place of the actuator and

press the buttons on the controller and the control box itself (if

applicable). If the light does not light up with the handset, replace

handset with a known good one and try to see if it lights up.

Once the battery is fully charged up to 24 to 28 volts, cycle the lift

(up, down, rotate) counting the cycles. If the battery is in good

condition, the lift should easily complete at least 15 cycles without

a load.

NOTES/RECOMMENDATIONS:

Aqua Creek Products Annual Pool Lift Safety

INSPECTION REPORT

PASS

FAIL

9/28/2022 1:39:29 PM PAGE - 11

N/A