Arch Pulsar 3 series Operator's Manual - Page 8

Browse online or download pdf Operator's Manual for Water Filtration Systems Arch Pulsar 3 series. Arch Pulsar 3 series 16 pages.

Print Page
Problem
Insuffi cient water
fl ow to chlorinator
Insuffi cient chlorine
in pool
Excess chlorine in pool
Air leaks
Chlorinator overfl ow
Arch Chemicals, Inc. ("Arch") warrants equipment of its manufacture and bearing its identifi cation to be free of defects in workmanship and material.
Arch's liability under this warranty extends for a period of two (2) years (excluding electrical components which carry a 1 year warranty) from the date
of installation as performed by an Authorized Commercial Dealer Representative and registered with Arch Water Chemicals via the Arch Commercial
Chlorinator Warranty Registration Card. Systems for which there is no Warranty Registration Card on fi le carry no warranty of any kind, expressed or
implied.
In addition, each system is covered by a sixty (60) day, 100% buy-back guarantee. If the original purchaser ("owner") is dissatisfi ed with the Pulsar® 3
Commercial Pool Chlorinator performance for any reason, they can return it to the Authorized Commercial Pool Dealer for a full refund. Th e equipment
must have received normal use and care, and Arch must be notifi ed in writing before the sixty (60) days have expired. Th ere is no reimbursement for
chemicals used during the sixty (60) days. Arch disclaims all liability for damage during transportation, for consequential damage of whatever nature,
for damage due to handling, installation or improper operation, and for determined suitability for the use intended by purchaser ("owner"). Arch makes
no warranties, either expressed or implied, other than those stated above. No Arch Representative or Authorized Commercial Dealer Representative has
authority to change or modify this warranty in any respect.
Arch warrants equipment parts of its manufacture and bearing its identifi cation to be free of defects in workmanship and material. Arch's liability under
this warranty extends for a period of ninety (90) days from the date of installation as performed by an Authorized Commercial Dealer Representative.
Th is warranty is restricted to Pulsar® 3 Chlorinator Parts purchased on a replacement basis.
Troubleshooter's Guide
Cause
Check water fl ow through spray nozzles
Inlet Shutoff Valve closed
Emergency Shut Off Valve in closed position
Feed rate/output too low
Chlorinator empty
No inlet water fl ow
Outlet/Shutoff Valve closed
Clogged Discharge Tubing
Briquettes stuck together
Clogged Briquette Tank Grid
Clogged Venturi System
Closed valves in venturi system
Automatic Controller Problem
Feed rate/output too high
Discharge Tubing not properly installed in fi ttings Reinstall Discharge Tubing
Discharge Valve seat failure
Scale prevents Discharge Valve from
properly seating
Pinched O-rings in Tubing Connectors
Discharge Tubing clogged
Clogged venturi system
Insuffi cient outlet suction
Emergency shutoff valve failure

WARRANTY POLICY

Pulsar® 3 Commercial Pool Chlorinator
Arch Water Chemicals, Inc.
1-800-4 PULSAR
SECTION B
Pulsar® 3 Parts
– 5 –
Solution
Clean spray nozzles with compressed air.
Do not use mechanical cleaning method.
Open Inlet Shutoff Valve
If ESV Valve is stuck, lower gently to reset
Solenoid Valve not operating
Check with Dealer
Increase feed rate/output on timer or ORP
Refi ll Briquette Tank with Pulsar® Plus
Briquettes
See insuffi cient water fl ow section
Open Outlet Shutoff Valve
Refer to Section A or Replace
discharge tubing
Tap side of Briquette Tank to loosen
Refer to Section A
Remove venturi – soak in tub with 50/50
mixture of water and Pulsar Plus Acid
Cleaner solution.
Open venturi system valves
Refer to automatic controller manual
Decrease feed rate/output on timer
Replace Discharge Valve Arm
Remove Discharge Valve Assembly and soak
in dilute acid to remove scale
Inspect O-rings on discharge side of feeder
Refer to Section A or Replace Discharge
tubing
See clogged venturi system solution
Check with Dealer
Check with Dealer