Clarke PPH15ND Operating & Maintenance Manual - Page 8
Browse online or download pdf Operating & Maintenance Manual for Air Compressor Clarke PPH15ND. Clarke PPH15ND 10 pages. Air compressor
Also for Clarke PPH15ND: Operating & Maintenance Instructions (17 pages), Operating & Maintenance Instructions (20 pages)
Print Page
STARTING THE COMPRESSOR
Initial Start-up
1.
Fully open the receiver drain cock, (located between the wheels).
2.
Start the engine, according to the instructions contained in the engine service
manual, and allow to run for 10 minutes.
3.
After a ten minute period, close the drain cock then ensure both air outlet
sliding valves are pushed fully INWARDS to close the outlet.
Pressure will build up in the receiver and eventually the air governor will
operate so that the engine runs off load. The pressure registered on the pressure
gauge should be 100psi.
4.
Slide the outlet taps outwards to allow air to escape from the outlets, and
slowly turn the pressure regiulator clockwise. Observe the pressure gauge.
When the pressure has dropped by approx. 20psi, the regulator will cut in
again. Close the sliding outlet valves and pressure in the air receiver will once
again increase
5.
Finally, stop the engine and set the pressure regulator to zero pressure (turned
fully anticlockwise) and attach the air hose and air tool.
6.
Open the sliding valves then set the pressure regulator to full pressure and
check for air leaks at the tool and connectors.
•
If leaks are apparent, stop the engine and set the regulator to zero pressure
(fully anticlockwise), press the trigger of the tool to ensure no air is present
in the airline, then rectify the problem before proceeding.
•
If no leaks are evident, set the outlet pressure to the desired value and
proceed to use the air tool in accordance with the manufacturers
instructions.
Fig.2
- 8 -
PUMP PARTS
No.
Description
1
Screw
2
Lower Cover
3
Casing
4
Bearing
5
Seal
6
Front Cover
7
Screw
8
Flywheel
9
Washer
10
Screw
11
Screw
12
Washer
13
Rear Cover
14
Oil Dipstick
15
Screw
16
Crankshaft
17
Connecting Rod
18
Piston Ring Kit
19
Circlip
20
Gudgeon Pin
21
Piston
22
Complete Piston
23
Cylinder
24
Valve Holder Plate
25
Head
26
Filter Cartridge
27
Intake Filter
28
Screw
29
Conveyor
30
Screw
31
Complete Seal Kit
32
Manifold
33
Automatic Discharge Valve
- 13 -
10ND
15ND
Part No.
Part No.
014013054
014013054
113149015
113149015
113167001
113167001
033027000
033027000
010053000
010053000
113149008
113149008
014013021
014013021
013160010
013160010
014005001
014005001
113160011
113160011
014013082
014013082
014005025
014005025
113149009
113149009
012036000
012036000
014010044
014010044
113167003
113167003
113150004
113149004
213115002
213167001
015098000
015023000
113115025
116025006
113164009
113115026
413115026
413167006
113169002
113167002
413149080
413167005
113150022
113149050
017024000
017003000
317026000
317001000
014002041
014002041
113150002
113150002
014006121
014006121
213168001
213167002
-
116091024
-
011158000