Alto-Shaam HALO HEAT HOT 2GO Operation And Care Manual - Page 2
Browse online or download pdf Operation And Care Manual for Merchandiser Alto-Shaam HALO HEAT HOT 2GO. Alto-Shaam HALO HEAT HOT 2GO 13 pages. Hot merchandiser
Print Page
U N P A C K I N G a n d S E T - U P
The Alto-Shaam Hot
Merchandiser has been
thoroughly tested, checked
for calibration, and inspected
to insure only the highest
quality cabinet is provided.
When you receive your unit, check for any possible
shipping damage and report it at once to the deliver-
ing carrier.
See Transportation Damage and Claims section located in
this manual.
The cabinet, complete with unattached items and
accessories, may be delivered in one or more packages.
Make certain the number of packages received matches
the packing list and the accompanying bill of lading.
Save all the information and instructions packed
inside the cabinet. Complete and return the warranty
card to the factory as soon as possible to insure
prompt service in the event of a warranty parts and
labor claim.
The unit should not be used in any area where it
may be affected by steam, grease, dripping water, or
high temperatures. The unit should be installed level
to work properly.
In order to maintain standards established by
the National Sanitation Foundation, models mounted
directly on top of an base or counter must be sealed to
both the base and floor, or counter, with a R.T.V. or
silastic meeting N.S.F. requirements. Otherwise,
these units must be mounted on legs of a sufficient
4" (102mm) height to provide minimum unobstructed
space beneath the unit. If these directions are not
followed, the warranty will become null and void.
(Refer to counter layout in this manual.)
NOTE:
Any claims for warranty must include
the full model number and serial number
C
of the cabinet.
– H O T M E R C H A N D I S E R
®
An identification tag is permanently mounted on the unit.
Position the unit so that the power supply cord is easily
accessible in case of an emergency. Plug the cabinet into a
properly grounded receptacle ONLY.
W A R M I N G C H A R A C T E R I S T I C S
The merchandiser is equipped with a special, low-
heat-density, heating cable. Through the Halo Heat
concept, the heating cable is mounted against the walls
of the warming compartment to provide an evenly
applied heat source, controlled by an electronic thermo-
stat. The design and operational characteristics of the
unit eliminate the need for a moisture pan or a heat cir-
culating fan. Through even heat application, the quali-
ty of food is maintained for short periods or for longer
time periods, up to several hours. The heated compart-
ment is equipped with an electronic thermostat, indica-
tor light, and digital display to monitor the interior air
temperature.
Read this manual thoroughly before using this mer-
chandiser, and keep this manual in a safe and easily
accessible area.
1. Before operating the merchandiser, clean the interior
and exterior of the unit with a clean, damp cloth and
mild soap solution. Rinse carefully.
2. Clean and install the side racks, cabinet wire shelves
and the bottom baffle pan.
3. Clean the glass with a window cleaner.
4. After final hook-up, locate the circuit breaker box
under the unit and flip breaker switch to the ON
position for full power to the merchandiser.
5. Check the operating temperature to make sure the
merchandiser is functioning within the guidelines
recommended for this unit.
Operation & Care Manual #835 • 1.
E L E C T R I C A L I N S TA L L AT I O N
EXAMPLE
SERIAL NUMBER AND WARRANTY CODE
IDENTIFICATION MODEL NUMBER
MODEL
xxx-xx
SERIAL NO.
WATTS
xxxx-xx
VOLTS
xxx
AC
1 PH
ALTO-SHAAM INC. MILW. WI. PAT. NO. 3521030
MAXIMUM RATED VOLTAGE
MAXIMUM RATED FREQUENCY
ENSURE POWER SOURCE
MATCHES VOLTAGE STAMPED
ON NAMEPLATE OF UNIT
S TA R T - U P
MAXIMUM RATED
WATTAGE
xxxx
xx
HZ