Chromalox GXF Series Installatie-instructies

Blader online of download pdf Installatie-instructies voor {categorie_naam} Chromalox GXF Series. Chromalox GXF Series 4 pagina's. Grounded teflon immersion heaters

Pagina afdrukken

Installation Instructions

Chromalox

Grounded Teflon

GXF/GXFL

FIRE/EXPLOSION HAZARD: This heater is not

intended for use in hazardous atmospheres where

flammable vapors, gases, liquids, or other com-

bustible atmospheres are present as defined in

the National Electrical Code. Failure to comply can

result in explosion or fire.

Chromalox type GTF series of Teflon

sion heaters are especially suited for most plating tank and other

corrosive solutions. It is inert to acid baths, anodizing and picking

operations up to 212˚F solution temperatures.

Sheath corrosion can result in a ground fault

which, depending upon the solution being heated,

can cause an explosion or fire.

IMPORTANT: It is the responsibility of the pur-

chaser of the heater to make the ultimate choice

of sheath material based upon his knowledge of

the chemical composition of the corrosive solu-

tion, character of the materials entering the solu-

tion, and controls which he maintains on the

process. Chromalox cannot warrant any electric immersion

heater against failure by sheath corrosion if such failure is the

result of operating conditions beyond our control.

Chromalox

Type GXF/GTF/GTFL Series

over-the-side immer-

SERVICE REFERENCE

DIVISION

SALES

REFERENCE

DATE

Immersion Heaters

GTF

GENERAL

1. Heater Construction Characteristics

A. High quality resistance wire held in place by compacted mag-

nesium oxide in stainless steel sheath and Teflon

B. Low watt density.

C. Grounded construction.

D. Over-temperature protection.

E. Epoxy filled, vapor tight, plastic terminal enclosure prevents

entry of contaminants.

F. Flexible conduit 3' long with 6" leadwire extension is stan-

dard.

The system designer is responsible for the safety

of this equipment and should install adequate

back-up controls and safety devices with their

electric heating equipment. Where the conse-

quences of failure could result in personal injury

or property damage, back-up controls are essen-

tial.

GTF

SECTION

(Supersedes PD444-1)

161-562652-001

DECEMBER, 2004

GTFL3

* Teflon

is a registered trademark of DuPont Co.

PD444-2

GTF6

covered.