Calflame 2008 G4 Instrukcja obsługi - Strona 12

Przeglądaj online lub pobierz pdf Instrukcja obsługi dla grill Calflame 2008 G4. Calflame 2008 G4 16 stron.

Appendix

Appendix

Problem: Smell of gas is present

Solution: Check for loose connections in the gas line. Perform a leak test following the procedure described in

this manual.

Problem

Burner does not ignite

Use the following procedure with the figure below.

Solution

Check the position of the sparker tip. It should be pointing forward towards the front of the burner.

•

Make sure there is a blue spark at the electrode tip to the burner.

•

Make sure the igniter wire is connected firmly to the valve ignition device and the electrode.

•

Make sure the valve orifice is free of any debris, dust or grease.

•

Make sure the valve orifice is aligned inside the front hole of the burner.

•

If there is no spark at all, replace the electrode or igniter wire.

Note: Turn off the gas at the source while troubleshooting.

Problem: Burner tube is misaligned over the orifice

Solution: Reposition the burner tube so that it is properly seated over the orifice.

Problem: Obstruction in the gas line

Solution: Remove the fuel line from grill. (Do not smoke or perform any maintenance in the vicinity of an open

flame.) Open the gas valve for one second to blow out any debris. Close off the gas valve and recon-

nect the fuel line securely.

Problem: Yellow Flame

Solution: Once the entire burner is operating, check the flame color to be sure that it is mostly blue. Some yel-

low at the tips may be present due to impurities in the fuel. If the flame is golden or yellow in color, the

reason could be seasoning salts, oil film, or other foreign matter on the burner.

Page 10

2008 G4 Grill Owner's Manual

LTR20081050, Rev. B