Battery Fighter BFP-024 Manual - Página 2
Procurar online ou descarregar pdf Manual para Carregador de bateria Battery Fighter BFP-024. Battery Fighter BFP-024 2 páginas. 12v 5a/24v 3a charger
Imprimir página
Stage 1) Qualification:
The following symptoms are incurred if the Red light continuously flashes:-
The battery voltage is detected too low, that is the battery voltage is lower than 4.0V (BFP-024), 2.0V (BFP-012),
•
the charging will not be commenced.
•
The battery is not being connected properly, please check the connection of battery is clean & good.
•
Reverse polarity connected.
Stage 2) Bulk Charge: Red Light On, Green Light Off, Constant Current = 5.0 Amps, Transition to Stage
3, Absorption Charge when battery voltage reaches 14.4 VDC.
Stage 3) Absorption Charge: Red Light On, Absorption Voltage = 14.4 VDC Transition to Float Charge
(Stage 4) when battery charging current drops below 2.5 amps.
Stage 4) Float Charge: Red Light Off, Green Light On. Float Voltage = 13.2 VDC. If an external load is
applied to the battery while the charger is in stage 3, Float Charge, and if the battery voltage drops below a
range between 11.5 to 12.0 VDC, then the charge cycle restarts.
Battery
17
Terminal
Voltage
(VOLTS )
16
15
14
13
12
11
10
9
8
7
Recharge
to
shown
Times
Recharge Times shown to
Recharge Times shown to
Battery
Ah
a 1 6
Fully
Pack
Recharge
6
Fully Recharge a 16 Ah Battery Pack
Fully Recharge a 16 Ah Battery Pack
0
Em pty
Em pty
Figure 1 Charging Graph: Float Maintain Charger 'Fighter' 12Vdc 5A
Ensure the battery is in good condition and safely able to be charged.
Light
Weight
On-Board
(Power
Tender)
Light Weight Mounted
Light Weight Mounted
Float Maintain Charger
Float Maintain Charger
12 Volt 6 Amp DC Output
12 Volt 5 Amp DC Output
12 Volt 5 Amp DC Output
Consta nt= 2.42 vp c
Consta nt= 2.42 vp c
vpc
= 2 .42
Constant
(14.4 V)
(14.4 V)
Transition:
Transition:
Transition:
Battery Voltage=14.4 Volts
Battery Voltage=14.4 Volts
Volts
= 1 4.5
Voltage
Battery
BULK
Current
Limit
(6 A)
(5 A )
0.5
1.0
1.5
2.0
2.5
(Hours)
Time
Charging
Charging
Charging
Charging
Algorithm
Charging Algorithm
Charging Algorithm
STANDARD
V)
(14.5
Floa t = 2.20 vp c
Floa t = 2.20 vp c
Transition:
Transition:
Transition:
Battery Current=2.5 Amp
Battery Current=2.5 Amp
Current
= 3 A mp
Battery
ABSORPTION
FLOAT
Constant
Constant
Voltage
Voltage
( 2.5 A )
(3 A)
3.0
3.5
4.0
4.5
5.0
Full
Full
80% Full
80% Full
Charging Time (Hours)
Charging Time (Hours)
Battery
Charging
Current
(AMPS)
Float = 2.20 vpc
(13.2 V)
(13.2 V)
V)
(13.2
(50 to 100 mA)
5.5
6.0
6.5
7.0
7.5
8.0
27.5
25.0
22.5
20.0
17.5
15.0
12.5
10.0
7.5
5.0
2.5
0