Bil-Jax ESCALATE TRAILER ET 5000W Manual de operação e serviço - Página 9

Procurar online ou descarregar pdf Manual de operação e serviço para Veículo utilitário Bil-Jax ESCALATE TRAILER ET 5000W. Bil-Jax ESCALATE TRAILER ET 5000W 20 páginas.

Imprimir página

1. Parts List

Hydraulic Fluid Levels

1. Remove cover from hydraulic pump. Check

fluid level in hydraulic reservoir.

Battery

1. Use hydrometer to check battery charge daily

or weekly, depending on frequency of use. If

the battery charge drops below 25% of full

charge (S.G. below 1.155 as corrected to

80°F) the battery must be recharged. Refer to

step 2 before charging battery.

2. Check the electrolyte level weekly. If battery

charge is low, add water to bring electrolyte

level just above plates.

If battery is fully charged, add water to raise

electrolyte to full mark in each cell.

2. Lower trailer deck. If oil level is below 3 inches

with deck down, add 1/2 quart of hydraulic oil.

Use BP type HLP-46 or 10w hydraulic oil.

NOTE: When trailer deck is raised, hydraulic

fluid level should be at least 1/2 of reservoir

volume.

3. Remove fill cap from surge brake reservoir.

Add DOT 3 brake fluid as needed to bring

fluid level to 1/2-inch below fill port.

3. Charge battery at one of the following charge

rates. The slow charge rate is preferred.

22 hours @ 5 amps

25 hours @ 20 amps

22 hours @ 50 amps

SERVICE

L L

B A

1 6

5 /

FILL CAP