Century Hearth FW300011 Руководство

Просмотреть онлайн или скачать pdf Руководство для Крытый камин Century Hearth FW300011. Century Hearth FW300011 2 страницы.

Печатать страницу
This manual describes the installation and operation of the Model FW300011 non-catalytic wood heater. This
heater meets US Environmental Protection Agency's emission limits for wood heaters. Under specific
conditions this heater has been shown to deliver heat at rates ranging from 11,800 to 32,300 BTU per hour.
Model No. FW300011
This unit has been listed by Warnock
Hersey Limited to meet or exceed ULC
S-627-00 Canada and UL 1482 U.S.
Contact your local building inspector
prior to installation.
A permit maybe required in your area.
2ft(635mm) HIGHER THAN
NEAREST POINT OF
3FT(1M) MIN
FROM ROOF
ROOF WITHIN 10ft(3M)
PENETRATION
MINIMUM OVERALL
G
HEIGHT FROM FLOOR
15FT(5M)
Unit must be placed on a noncombustible floor protection equivalent to 3/8" millboard.
Consult your local building authorities for further information.
CAUTION:
HANDLE
CERAMIC BAFFLE IS FRAGILE.
Twist spring handle
BEFORE REMOVING SECONDARY AIR
clockwise motion while pushing on to
TUBES SUPPORT CERAMIC BAFFLE.
handle; spring handle will "thread" down
to desired location.
18
Desired Burn Setting
16
Low
Med / Low
17
Med / High
High
1 . M a x i m u m b u r n t i m e s a n d h e a t o u t p u t s a r e b a s e d o n l a b o r a t o r y t e s t i n g u s i n g f u l l l o a d s o f
s e a s o n e d h a r d w o o d s , a n d m a y v a r y i n i n d i v i d u a l u s e d e p e n d i n g o n h o w t h e s t o v e i s o p e r a t e d , t y p e a n d m o i s t u r e
c o n t e n t s o f f u e l , a n d o t h e r f a c t o r s . M a x i m u m b u r n t i m e s a r e a c h i e v e d u n d e r d i f f e r e n t o p e r a t i n g c o n d i t i o n s t h a n a r e
m a x i m u m h e a t o u t p u t s .
2 . T h e s e v a l u e s a r e b a s e d o n o p e r a t i o n i n b u i l d i n g c o d e - c o n f o r m i n g h o m e s u n d e r t y p i c a l W i n t e r c l i m a t e c o n d i t i o n s i n
t h e n o r t h e a s t e r n U . S . I f y o u r h o m e i s o f n o n s t a n d a r d c o n s t r u c t i o n ( e . g . U n u s u a l l y w e l l - i n s u l a t e d , b u i l t u n d e r g r o u n d , o r
i f y o u l i v e i n a m o r e t e m p e r a t e c l i m a t e ) , t h e s e m a y n o t a p p l y. S i n c e s o m a n y v a r i a b l e s a f f e c t p e r f o r m a n c e , c o n s u l t y o u r
C F M A u t h e r i z e d D e a l e r t o d e t e r m i n e r e a l i s t i c e x p e c t a t i o n s f o r y o u r h o m e .
3 . U n d e r s p e c i f i c c o n d i t i o n s u s e d d u r i n g E PA e m i s s i o n t e s t i n g .
NOTE: Retain this sheet for future reference
6" Flue Required
Figure A: Clearance from combustible constructions
A minimum clearance of 18" (457mm) to the chimney connector
may be required by the authority having jurisdiction.
From Heater
From Chimney Connector
A
Sidewall..........18-1/2" (470 mm)
D
Sidewall................24-1/2" (622 mm)
B
Backwall...............14" (351 mm)
E
Backwall................17-1/2" (445 mm)
C
Corner..................11" (279 mm)
F
Corner...................17-1/2" (445 mm)
G
Ceiling..................57-3/4" (1467 mm)
BACK WALL
B
E
8"(203mm)
A
D
*16
**18
C
8"(203mm)
8"(203mm)
Figure "A"
*16"(406mm) U.S.A.
**18"(457mm) Canada
CAUTION: Do not open fire-door to a point
where it would be in contact with the
combustible sidewall.
OPTIONAL FAN
An optional heat exchange blower is available
for this wood burning appliance. To order please
see the local dealer where you purchased
SPRING
in counter
your appliance.
CAUTION: BRICK FOR ASH DRAWER
MUST BE INSTALLED BEFORE
OPERATION OF WOOD HEATER
Inlet Air Control Settings
Inlet Air Setting
Approx. BTU Output
Closed Fully
¼ Open
¾ Open
Fully Open
Part No S19995 Rev07
1
9
10
BACK WALL
C
F
13
F
13
15
Disposition Des Briques
Diseño de colocación de los ladrillos
ITEM NO.
PARTS LIST
NO.
LEYENDA NO.
DESCRIPTION
1
DOOR ASSEMBLY
2&3
GLASS AND GASKET
3
1/8" GLASS GASKET x 6'
4
5/8" DOOR GASKET x 6'
5
SPRING HANDLE
6
AIR CONTROL SPRING HANDLE
7
GLASS CLIP
12,000
8
9
HINGE PIN
13,400
10
PUSH NUT
17,700
11
FIREBRICK LT 7-3/4"x4-7/16"x1-1/4"
55,100
12
FIREBRICK LT 4-1/2"x4-7/16"x1-1/4"
13
FIREBRICK LT 9"x4-7/16"x1-1/4"
14
FIREBRICK LT 9"x2-1/2"x1-1/4"
15
FIREBRICK FOR ASH DRAWER
16
SECONDARY AIR TUBE
17
COTTER PIN
18
CERAMIC BAFFLE
19
ASH DRAWER ASSEMBLY
MADE IN/FAB AU/HECHO EN CANADA BY CFM Corporation, 2695 Meadowvale Blrd, Mississauga, ON L5N 8A3 800-668-5323 www.cfmcorp.com
2
5
14
13 13
13 13
13
11
11
11
13
13
13
11
12
13
Brick Pattern
LISTE DES PIÉCES
DESCRIPTION
PORTE MONTÉE
VITRE DE JOINT D'ÉTANCHEITÉ
JOINT DE LA VITRE 1/8po x 6pi
JOINT DE LA PORTE 5/8po x 6pi
POIGNÉE À RESSORT
POIGNÉE POUR L'ADMISSION D'AIR
FERRURE POUR LA VITRE
SCREW
VIS
GOUPILLE DE CHARNIÈRE
ÉCROU À RESSORT
BRIQUE 7-3/4pox4-7/16pox1-1/4po
BRIQUE 4-1/2pox4-7/16pox1-1/4po
BRIQUE 9pox4-7/16pox1-1/4po
BRIQUE 9pox2-1/2pox1-1/4po
BRIQUE POUR LE CENDRIER
TUBE D'AIR SECONDARE
GOUPILLE FENDUE
DÉFLECTEUR DE CÉRAMQUE
L'ASSEMBLEE DE TROIR DE CENDRE
7
3
4
8
6
19
LISTA DE PIEZAS
QTY
PART NO.
QTÉE
NO.de PC
DESCRIPCIÓN
CANT. ART NO.
UNIDAD DE PUERTO
1
S31343
VIDRIO Y EMPAQUETADURA
1
S31141
EMPAQUETADURA DE 1/8" PARA EL VIDRO x 6'
1
S15001-6
1
EMPAQUETADURA DE 5/8" PARA LA PUERTO x 6'
S15011-6
MANGO CON RESORTE
1
S11007
MANGO CON RESORTE PARA EL REGULADOR DEL AIR
1
S11008
7
PRESILLA PARA EL VIDRIO
S37034
TORNILLO
7
S11086
DEPIENDA ALFILER
2
S11005
2
UNIDAD DEL DEFLECTOR
S11090
LADRILLO REFRACTARIO 7-3/4"x4-7/16"x1-1/4"
4
S16222
LADRILLO REFRACTARIO 4-1/2"x4-7/16"x1-1/4"
1
S16046
LADRILLO REFRACTARIO 9"x4-7/16"x1-1/4"
15
S16040
LADRILLO REFRACTARIO 9"x2-1/2"x1-1/4"
1
S16216
LADRILLO PARA DEPÓSITO DE CENIZAS
1
S16214
4
TUBO SECONDARIO DEL AIRE
90000160
ALFILER DE COTTER
4
S11421
DEFLECTOR DE CERÁMICA
1
90000161
ASAMBLEA DE CAJON DE CENIZA
1
S31300