DryAIR Hose Reel II Operatör El Kitabı - Sayfa 13
Araçlar DryAIR Hose Reel II için çevrimiçi göz atın veya pdf Operatör El Kitabı indirin. DryAIR Hose Reel II 20 sayfaları.
Sayfayı YazdırIntroduction
Operating Features
Danger! It is very important that you read and understand this manual
before operating the reel! Failure to follow the procedures and cautions in
this manual could lead to injury or possible death!
The DRYAIR hose reel's primary purpose is dispense and collect fluid
circulation hose on job sites...primarily with respect to ground thaw and/
or concrete cure operations.
The hose reel includes the following controls
•
Spool directional and power controls
Spool rotational speed (RPM)
•
•
Two methods of spool rotation activation... both are "hands-off".
-Momentary foot switch – a default setting when in the "load"
position.
-Auto-feed switch – a default setting when in the "unload"
position.
The drive is always engaged and braking controls are automatic.
•
Therefore, there are no brakes to engage or disengage
Drive Features & Power
Requirements
The reel can be run off a 115VAC, 15 amp circuit.
•
Required Wire Guage / Feet
AWG 14
AWG 12
AWG 10
Reel RPM and directional control is handled through a variable speed/soft-start AC motor control adjustable frequency drive. The vari
•
able frequency drive is a phase converter...1 to 3 phase.
The reel motor is a 1 HP 3-phase continuous duty electric motor.
•
Drive and motor protection against inertial forces is provided by an adjustable torque-limiter clutch located between the motor/gear box
•
and the reel spool. The torque limiter clutch provides quick braking action (less than half a revolution with a loaded reel at full rpm [20
RPM]) and a smooth interface between the spool's high inertial forces and unit's drive components.
Reel Capacities
The Model HR 6000 Hose Reel is designed to carry up to 6000 feet of 3/4" hose (3/4" I.D. x 1.125"O.D.). 6000 or 3000 hose packages
•
are available.
Transportation & Storage
The reel can be transported by common carrier. The reel can be loaded using a forklift (accessible from all 4 sides). Slings can also be
•
used.
A transport trailer, specifically designed for the reel, is also available.
•
As the reel is remote and not connected to the heating system, it can be stored out of the way or off the site when it is not needed.
•
A tarp cover is provided to ensure weather and UV protection for the fluid circulation hose.
•
Introduction
DANGER! WARNING!
0 - 100
100 - 200
200 -
hose reel overview
3-1