Kohler Magnum 20 HP Kullanıcı El Kitabı - Sayfa 13

Motor Kohler Magnum 20 HP için çevrimiçi göz atın veya pdf Kullanıcı El Kitabı indirin. Kohler Magnum 20 HP 17 sayfaları. Horizontal crankshaft
Ayrıca Kohler Magnum 20 HP için: Kullanıcı El Kitabı (17 sayfalar)

Sayfayı Yazdır
Kohler Magnum 20 HP Kullanıcı El Kitabı

Troubleshooting

When a problem occurs, be sure to check the simple causes which at first, may seem too obvious to be
considered. For example, a starting problem could be caused by an empty fuel tank. Some common causes of
engine troubles are listed in the following table.
Do not attempt to service or replace major items or any items that require special timing or adjustment procedures
(governor, valves, etc.). Have your Kohler Engine Service Dealer do this work.
Possible Cause No
Problem
Fuel
Will Not Start
•
Hard Starting
•
Stops Suddenly
•
Lacks Power
Operates Erratically
Knocks or Pings
Skips or Misfires
Backfires
Overheats
High Fuel Consumption
Storage
If the engine will be out of service for approximately
two months or more, use the following storage
procedure:
1. Clean exterior surfaces of the engine.
2. Change oil and filter when engine is still warm
from operation. See "Changing Oil" and "Oil Filter"
on page 9.
3. The fuel system must be completely emptied, or
the gasoline must be treated with a stabilizer to
prevent deterioration. If you choose to use a
stabilizer, follow the manufacturers
recommendations, and add the correct amount for
the capacity of the fuel system. Fill the fuel tank
with clean, fresh gasoline. Run the engine for 2-3
minutes to get stabilized fuel into the carburetor.
To empty the system, run the engine until the tank
and system are empty.
4. Remove the spark plugs. Add one tablespoon of
engine oil into each spark plug hole. Install plugs
but do not connect plug leads. Crank the engine
two or three revolutions.
5. Store the engine in a clean, dry place.
Improper
Dirt In
Fuel
Fuel Line Grass Screen
•
•
•
•
•
•
•
•
•
•
•
•
•
Dirty
Incorrect
Oil Level
Overloaded
•
•
•
•
•
•
•
•
•

Parts Ordering

The engine Specification, Model, and Serial Numbers
are required when ordering replacement parts from
your Kohler Engine Service Dealer. These numbers are
found on the identification plate which is affixed to the
engine shrouding. Include letter suffixes if there are
any. See "Engine Identification Numbers" on page 4.
Always insist on genuine Kohler parts. All genuine
Kohler parts meet strict standards for fit, reliability, and
performance.

Major Repair

Major repair information is available in Kohler Engine
Service Manuals. However, major repair generally
requires the attention of a trained mechanic and the
use of special tools and equipment. Your Kohler
Engine Service Dealer has the facilities, training, and
genuine Kohler replacement parts necessary to
perform the service. For Sales and Service assistance
call
1-800-544-2444 (U.S. and Canada) or contact your
Kohler Engine Dealer or Service Distributor, they're in
the Yellow Pages under Engines–Gasoline.

Model Designation

Model MV18S for example: M designates MAGNUM
engine, V designates the vertical crankshaft, and 18
designates horsepower. A letter suffix designates a
specific version as follows:
Suffix
S
T
Engine
Dirty Air
Cleaner
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
Designates
Electric Start
Retractable Start
Faulty
Spark Plug
•
•
•
•
•
•
•
•
13