BIOMICROBICS BioBarrier Servis Kılavuzu - Sayfa 2

Su Sistemi BIOMICROBICS BioBarrier için çevrimiçi göz atın veya pdf Servis Kılavuzu indirin. BIOMICROBICS BioBarrier 12 sayfaları.

Sayfayı Yazdır

GENERAL INFORMATION

The BioBarrier

0.5, 1.0 and 1.5 systems are certified by the NSF International/ American National Standards Institute Organizations to meet NSF/ANSI

Standard 40, Class 1 certification for single residence wastewater treatment devices, NSF/ANSI Standard 245 for nitrogen reduction, and NSF/ANSI

Standard 350 Class R for residential water reuse applications. All BioBarrier

you have questions regarding any Bio-Microbics products please contact us at:

DELIVERY INSPECTION

The BioBarrier

system has been carefully manufactured, checked and tested at the factory before shipment. Before and after uncrating the unit, check

the packaging for signs of shipping damage. If there is evidence of damage or abuse reject the shipment notify BioMicrobics, Inc. immediately at

800-753-3278 or (913) 422-0707.

THE BIOBARRIER

The BioBarrier

Membrane Bioreactor combines the activated sludge treatment process with the exceptional clarification properties of a membrane.

The System is installed in locally approved tanks, in a two compartment tank, or multiple tanks, with the membrane module always in the last

compartment/ tank. Primary treatment consists of sedimentation and separation of floatables and solids, and occurs in the first compartment. The

and Total Kjeldal Nitrogen.

When nitrogen removal is needed the system (The BioBarrier

at least three compartments, with exactly two compartments in the second or final tank. The first compartment or tank provides primary treatment -

sedimentation and separation of floatables and solids, and is equipped with an outlet screening device called SaniTEE

compartments must be in the same tank, and the second compartment is where denitrification takes place under anoxic conditions. The third

compartment, the aeration/membrane zone, is separated from the anoxic zone by a baffle wall between the two zones to allow nitrified waste to enter

into the anoxic area for denitrification.

Only qualified service persons should open any access port or cover on the system. Hazards such as electric shock and Infectious organisms exist in

these areas. Persons coming in contact with wastewater, must immediately wash and disinfect all exposed areas and contact your personal physician.

Failure to do so could result in severe sickness or death.

NSF Standard 350 Class R Restricted Indoor Urban Reuse Water

The BioBarrier

system has been tested under NSF Standard 350 Class R (Residential) and is

capable of treating residential wastewater for restricted indoor urban water reuse, which is toilet and

urinal flushing. The system design requires a holding tank and plumbing system for reuse water and

shall meet all applicable codes; have proper backflow prevention and protection against cross

connections; and is the responsibility of the local designer/installer. When the reuse water is used

for toilet and urinal flushing, additional disinfection should be considered to provide adequate

assurance in preventing microorganism growth in the treated reuse water storage tank and as

required by applicable codes. The reuse tank shall be located after the BioBarrier

tank shall also incorporate an overflow that allows excess reuse water to be dispersed in a locally

SERVICE MANUAL

1-800-753-FAST (3278) or +1 (913) 422-0707

E-mail: [email protected]

SYSTEM

products are ETL certified for safety (electrical, environmental, etc.). If

second compartment/tank can be used to enhance the BioBarrier's

nitrogen reducing capabilities. The second compartment houses

the BioBarrier system. The BioBarrier's blower aerates the

wastewater for naturally occurring bacteria (biomass) to grow and

treat the sewage. The membrane prevents most particles from

0.5-N, 1.0-N, 1.5-N) consists of a tank with three compartments, or two tanks totaling

approved soil dispersal system or released into a sanitary sewer system. A potable water make up

system shall also be available to supply water when treated reuse water is not available. This potable

water make up system shall include a properly designed backflow preventer that meets all applicable

codes.

NSF Standard 350 Class R Unrestricted Outdoor Urban Reuse Water

The BioBarrier® system has been tested under NSF Standard 350 Class R (Residential) and is

system. This

capable of treating residential wastewater for unrestricted outdoor urban water reuse, which is

being

discharged

into

environment.

The clean water is discharged to the receiving

environment by the effluent pump. The aerator

also helps limit the rate of fouling on the

membrane sheets. This is a continuous

process provided the biomass is supplied with

waste (food) and air in a suitable environment.

A vent pipe allows for venting of non-harmful

by-products created by the process. The entire

process produces effluent with very low levels

of bacteria, organic matter (BOD), solids (TSS)

. The second and third

the

receiving