Dover PSG Mouvex CC10-24 Експлуатація та технічне обслуговування установки - Сторінка 11
Переглянути онлайн або завантажити pdf Експлуатація та технічне обслуговування установки для Водяний насос Dover PSG Mouvex CC10-24. Dover PSG Mouvex CC10-24 18 сторінок.
Друкувати сторінку
WARNING
Dangerous voltage.
Can cause
injury and death.
WARNING
Hazardous pressure
can cause
personal injury
or property damage.
WARNING
The weight ot the parts
can be dangerous and may
provoke bodily injuries
or material damages.
CAUTION
Excessive temperature
can cause injury
or severe damage.
Before any dismantling, make sure that the pump has been drained and take all the necessary precautions to prevent it from starting up.
The pump must not start up, even accidentally.
8.1 Dismantling on side opposite to drive system
Unscrew the screws 723, and remove the cover 712 and the
seal 714.
Remove circlip 537.
Carefully clean the shaft end (remove any trace of paint, oxi
dation, burrs...).
Unscrew the 4 screws 410.
Unscrew the 4 screws 411 fitted with their nut 412 and place
them in the 2 tapped holes T where are the bosses.
Screw up the 2 screws at the same time so that the endplate
is gradually released along the centre line.
NT 1010P00 09 20 CC1024 A e
8. DISMANTLING - REASSEMBLY
DISCONNECT THE ELECTRICITY SUPPLY
BEFORE ANY MAINTENANCE OPERATION.
FAILURE TO RELEASE ALL SYSTEM AIR AND
WHEN EQUIPPED, HYDRAULIC PRESSURE,
CAN CAUSE PROPERTY DAMAGE, PERSONAL
INJURY OR DEATH.
BE CAREFUL WITH THE WEIGHT OF THE
PARTS WHEN THEY ARE BEING REMOVED.
THE SURFACES OF THE PUMP CAN BE AT
A TEMPERATURE LIABLE TO CAUSE INJURY
OR SEVERE DAMAGE.
WARNING
Hazardous pressure
can cause
personal injury
or property damage.
WARNING
Hazardous or toxic fluids
can cause serious injury.
CAUTION
Slippery lubricant.
Spills should be
cleaned up.
WARNING
Any unforeseen startup
can cause serious
injuries or important
material damages.
11/18
DISCONNECTING THE FLUID OR PRESSURE
CONTAINMENT COMPONENTS DURING
PUMP OPERATION CAN CAUSE SERIOUS
PERSONAL INJURY, DEATH OR MAJOR
PROPERTY DAMAGE.
IF PUMPING HAZARDOUS OR TOXIC FLUIDS,
THE SYSTEM MUST BE FLUSHED PRIOR TO
PERFORMING ANY SERVICE OPERATION.
THE PUMP LUBRICANT IS VERY SLIPPERY
AND MAY CAUSE SERIOUS INJURY. ANY
SPILLS MUST BE CLEANED UP.
TAKE ALL NECESSARY MEASURES TO REN-
DER ANY START-UP, EVEN ACCIDENTAL,
OF THE PUMP DURING THE WORK
IMPOSSIBLE.