Attwood 4640 Instrucciones de instalación - Página 2

Navegue en línea o descargue pdf Instrucciones de instalación para Bomba de agua Attwood 4640. Attwood 4640 2 páginas. Tsunami aerator pump

Imprimir página

LIVEWELL CONNECTION INSTRUCTIONS

See Accessories Chart for sizes / part numbers of Outlet Hose and

Spray Head.

1. Connect outlet hose from the aerator outlet fitting to the Spray

Head. Use a hose clamp at each end of the hose. (Figure 3)

IMPORTANT: Route the hose as straight as possible with an upward

angle. Avoid dips or sharp bends that can create airlock and hinder

water flow.

2. An aerator pump can be connected to the bottom of a livewell to

recirculate water within the tank.

Figure 3

Intake

WIRING INSTRUCTIONS

The power source to the pump must be a 12-volt DC battery ONLY.

Protect circuit with fuse (see chart) and make all wire connections

above the highest possible water level, using marine grade wire

connectors only. Waterproof all connections with suitable materials.

(Figure 4)

CAUTION: Failure to make waterproof connections and fuse pump

properly will void the product warranty.

Figure 4

Fuse Holder

2-Terminal

On/Off Switch

Brown Wire

Aerator

Spray Head

Smooth-Bore

Reinforced Hose

72" (183cm) Max. Length

From (+) Terminal to Fuse

Black Wire

(neg)

(pos)

12 Volt DC

(Power Source)

CARE AND MAINTENANCE

WARNING

If Aerator is installed thru-hull, BOAT MUST BE OUT OF THE

WATER to remove or replace aerator motor cartridge.

1. With boat out of water, occasionally remove Motor Cartridge and

check pump to be certain debris is not restricting or jamming the

impeller. Hold outlet with one hand and depress red locking tab

with other. Twist Motor Cartridge counter-clockwise and remove

from housing. (Figure 5)

Figure 5

Motor Cartridge

Unlock

Lock

Red Tab

"O" Ring

2. Be sure "O " ring is not damaged, nicked or worn. Lubricate the

"O " ring area with vegetable oil to ease re-assembly.

3. To install new Motor Cartridge (H), see Accessories Chart for

part number. Motor must match housing color: 500 Series = RED,

800 = BLUE, 1200 = GRAY.

4. Align motor cartridge red tab with slot on aerator housing. Push in

and turn clockwise.

WARNING

To avoid leaking or sinking, the RED TAB MUST BE LOCKED AND

EXTENDING through aerator housing slot.

ATTWOOD AERATOR PUMPS LIMITED WARRANTY

This Attwood Aerator Pump carries a three (3) year warranty. See

product catalog or www.attwoodmarine.com for details.

1016 N. Monroe Street, Lowell, MI 49331-0260 www.attwoodmarine.com

Red Tab

Must Be Extending Thru Slot