Kohler Magnum 20 HP Kullanıcı El Kitabı - Sayfa 6

Motor Kohler Magnum 20 HP için çevrimiçi göz atın veya pdf Kullanıcı El Kitabı indirin. Kohler Magnum 20 HP 17 sayfaları. Horizontal crankshaft
Ayrıca Kohler Magnum 20 HP için: Kullanıcı El Kitabı (17 sayfalar)

Sayfayı Yazdır

Also read the operating instructions of the equipment this engine powers.

Pre-Start Checklist

! Check oil level. Add oil if low. Do not overfill.

! Check fuel level. Add fuel if low.

! Check cooling air intake areas and external

surfaces of engine. Make sure they are clean and

unobstructed.

! Check that the air cleaner components and all

shrouds, equipment covers, and guards are in

place and securely fastened.

! Check that any clutches or transmissions are

disengaged or placed in neutral. This is especially

important on equipment with hydrostatic drive. The

shift lever must be exactly in neutral to prevent

resistance which could keep the engine from

starting.

WARNING: Lethal Exhaust Gases!

Engine exhaust gases contain poisonous carbon

monoxide. Carbon monoxide is odorless, colorless,

and can cause death if inhaled. Avoid inhaling exhaust

fumes, and never run the engine in a closed building or

confined area.

Cold Weather Starting Hints

1. Be sure to use the proper oil for the temperature

expected. See Figure 2 on page 4.

2. Declutch all possible external loads.

3. Set speed control at part throttle position.

4. A warm battery has much more starting capacity

than a cold battery.

5. Use fresh winter grade fuel. NOTE: Winter grade

gasoline has a higher volatility to improve starting.

Do not use gasoline left over from summer.

Starting

1. On a Cold Engine – Place the throttle control

midway between the ''slow'' and ''fast''

positions. Place the choke control into the ''on''

position.

On a Warm Engine (Normal Operating

Temperatures) – Place the throttle control

midway between the ''slow'' and ''fast''

positions. Place the choke control into the ''off''

position.

Operating Instructions

2. Activate the starter switch. Release the switch as

soon as the engine starts.

NOTE: After starting the engine, it may be

NOTE: Do not crank the engine continuously for

NOTE: If the engine develops sufficient speed to

If the starter does not turn the engine over, shut

off starter immediately. Do not make further

attempts to start the engine until the condition is

corrected. Do not jump start using another battery

(refer to "Battery" below). See your Kohler Engine

Service Dealer for trouble analysis.

3. On a Cold Engine – Gradually return the choke

control to the ''off '' position after the engine starts

and warms up.

Stopping

1. If possible, remove the load by disengaging all

PTO attachments.

2. Move the throttle control to the ''slow'' or ''low''

idle position. Allow the engine to run at idle for 30-

60 seconds; then stop the engine. If the carburetor

on the engine is equipped with a fuel solenoid,

move the throttle control back up between half

and full throttle just before stopping the engine.

Battery

A 12 volt battery is normally used. Refer to the

operating instructions of the equipment this engine

powers for specific battery requirements.

If the battery charge is not sufficient to crank the

engine, recharge the battery (see page 11).

necessary to leave the choke partially

''on'' for a few minutes before moving it

to the ''off'' position.

more than 10 seconds at a time. If the

engine does not start, allow a 60 second

cool down period between starting

attempts. Failure to follow these

guidelines can burn out the starter motor.

disengage the starter but does not keep

running (a false start), the engine rotation

must be allowed to come to a complete

stop before attempting to restart the

engine. If the start is engaged while the

flywheel is rotating, the starter pinion and

flywheel ring gear may clash, resulting in

damage to the starter.