Clarke PIONEER 215 운영 및 유지보수 지침 매뉴얼 - 페이지 11

{카테고리_이름} Clarke PIONEER 215에 대한 운영 및 유지보수 지침 매뉴얼을 온라인으로 검색하거나 PDF를 다운로드하세요. Clarke PIONEER 215 12 페이지.

페이지 인쇄
Clarke PIONEER 215 운영 및 유지보수 지침 매뉴얼
OPERATING INSTRUCTIONS
Switching the air compressor ON
The compressor will make a continuous loud noise when the tank is charging -
this is normal.
1.
Lift the red On/Off switch located on
top of the pressure regulator.
• The compressor will charge the
main tank to 10 bar (145 psi) then
switch off.
• The compressor will restart
automatically whenever the
pressure in the main tank falls
below a certain level.
2.
Check the operation of the safety
valve, under pressure daily, by pulling
the ring as shown in figure 6. Air
should be released you pull the ring and stop when the ring is released.
• If the valve does not operate as described, or if the valve is stuck, it must
be replaced by qualified service personnel before using the compressor.
WARNING!
Do not remove or attempt to adjust the safety valve.
3.
Select the pressure you need using
the pressure regulator. See figure 7.
4.
Open the outlet tap.
Figure 6
Pressure
regulator
Output pressure
gauge
Figure 7
14

ASSEMBLY

WARNING!
Before assembling and using the air compressor, make sure that you have
read and understood all of the safety instructions.
Installation
Take care when lifting the compressor from the packaging.
CAUTION! Do not lift the compressor from the gauge of fittings assembly. Get
assistance if necessary. This unit weighs 23 kg.
After removing the compressor from its packaging, check the integrity of the
unit, making sure it has not been damaged in transit.
Positioning the air compressor
This compressor should be positioned on a
stable, flat surface (or one with a maximum
inclination of 15
O
). See figure 1, and ensure
it is completely stable
Do not cover or box in the compressor.
Always position it at least 50cm from any
obstacle or wall
Make sure the compressor has good all
round ventilation.
15
max
1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 3 4
1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 3 4
1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 3 4
1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 3 4
Figure 1
11
0